2010 Ford Flex Complaints

Vehicle was shaking in the rear area for some time at highway speeds. I took the vehicle in to the local tire shop to get the alignment checked. After that the vehicle still shook. I took the vehicle back to the tire shop and the alignment was already off quite a bit in the back tires. I took the vehicle in to the local ford dealership and was informed that the rear passenger toe link was cracking. This was replaced and the vehicle still shakes/vibrates a little bit at highway speeds. After tire rotation ,the vibration is getting better. The toe link had caused the tires to wear down inconsistently, which caused the secondary vibration.

constant failure of the blend door actuator causes a clicking noise in the cabin upon starting the vehicle, or switching from vent mode to defrost mode. Also happens intermittently when activating the air conditioning. the clicking is loud enough to be heard from outside the vehicle. Unit has been replaced 4 times in 2 years. usually only lasts about a month before the unit starts to click again.

UNKNOWN I was on the highway during dry conditions, and very suddenly fishtailed and swerved into another lane. Caused an accident. Could have been much worse. Rear driver's side wheel is not facing forward - tow driver says looks like a broken toe link. Insurance company has possession of the vehicle and will likely total the car, with no inspection by a repair shop.

My 2010 Ford Flex began inadvertently surging forward in acceleration without me making it do this exactly 3 months after I purchased the vehicle. The Ford Dealer was unable to re-produce the problem on several occasions and said my vehicle was fine. No error messages reported in the computer. This has continued to happen sporadically since ownership. I have had another Ford Dealership (as well as an independent mechanic) try and reproduce and diagnose the problem with no luck. Several weeks ago I was driving my vehicle in my residential neighborhood when all of a sudden my car surged forward with great acceleration with no warning. I had to swerve into a driveway and cut the vehicle off to get the vehicle under control. I am 82 and have a heart condition. This safety issue is critical as someone could get hurt or killed. Ford has several complaints of this happening with several models. I believe it is a Ford design flaw in the vehicles electronic throttle system. Ford Corporate was p...

Rear suspension toe-link failure on left side. Incident occurred without any notice at speed of approximately 30-35 MPH on highway after pulling away from having stopped for traffic light at intersection. Vehicle swerved uncontrollably to right at approximately 45 degrees, then began slow drift to left during which I was finally able to regain control by applying throttle pressure and torque to front wheels to pull it forward. This fortunately occurred on a multi-lane roadway with no other traffic to either side of vehicle. No insurance claim has been filed as vehicle was otherwise undamaged during this event, but it was towed to Vogler Ford, Carbondale, IL, where it remains in their service lot. It is available for inspection. I do not know if they have discussed this situation with any Ford Motor Co. personnel.