2009 Ford Flex Complaints

On February 26, 2026, I purchased a used 2009 Ford Flex VIN from Header’s Auto Sales. At time of delivery, the vehicle was equipped with tires that did not meet the manufacturer’s required load rating for this vehicle. A licensed mechanic provided a safety assessment confirming the tires were improperly load-rated and unsafe to carry the vehicle load. We were not informed of this issue at sale. To make the vehicle safe to drive, I replaced all 4 tires at my cost. Improper load-rated tires can result in tire failure, loss of vehicle control, and crash. Dealer sold vehicle "as-is" without disclosure of this safety defect.

You can be driving down the road, and all your gauges will stop working, and all the warning lights on the dash will light up. The first time this happened my wife got stuck at a gas station all the warning lights were on and the car would not start, people tried to jump it and it would not affected at all. I looked on the internet and found were someone said to beat on the passenger side floorboard, I called my wife and told her to try that, and when she did the car would start. It doesn't do it all the time, you never know when it's going to happen. We have to just stomp on the passenger floor to get everything to start working again. If I had not found this information from somebody else on the internet my wife would have been stuck about a hundred miles from home. I've taken it to the Ford house and they say they've never heard of anything like this but I know it's happened before two other people that's how I knew to stomp on the floorboard on the passenger side.

Rear subframe rusted at bolt mount. Vehicle could have experienced catastrophic failure wihle driving. Independent service center diagnosed and documented rusted area and potential for failure. Noise would happen during acceleration/deceleration but not in wet weather conditions. Until diagnosed as unsafe to drive, vehicle drove with rear passenger side sitting on rear spring, potentially causing spring to rust prematurely.

The door ajar sensor malfunctions and is crazy expensive to fix. There are numerous posts and videos online of workarounds bcz it’s so common but they don’t seem safe since that’s a safety feature and the workarounds are simply a way to trick or bypass the warning sensors since the doors are actually closed in most cases. Ford needs to take ownership of this and issue a recall. There’s a tire pressure sensor failure as well.

Was driving and the steering wheel became stiff. I received no warnings indications or lights on the dash. I had to give it a hard turn to get it to a parking lot and have it towed to a dealership.