2013 Ford Flex Complaints

What component or system failed or malfunctioned, and is it available for inspection upon request? MULTIPLE DRIVER AID FUNCATIONS IN-OP. DRIVER DOOR LOCKS WILL NOT LOCK OR UNLOCK, DRIVER DOOR LOCK AND UNLOCK SWITCH WILL NOT OPERATE ANY LOCKS, PASSENGER DOOR MIRROR WILL NOT MOVE, SEAT MEMORY WILL NOT SAVE, REAR VIEW MIRROR WILL NOT AUTO DIM AND THERE IS NO MANUAL OPTION TO ADJUST THE MIRROR RESULTING IN IMPACTED NIGHT VISABLITY, REAR VIEW CAMERA DOES NOT DISPLAY ON SCREEN BUT WILL BEEP WHEN CLOSE TO AN OBJECT. NOT CODES OR DASH WARNINGS DISPLAYED TO STORED. How was your safety or the safety of others put at risk? IMPACTED VISIBLY WHILE DRIVING. UNABLE TO ADUST PASSENGER MIRROR TO SEE BLINK SPOT OR ALONG PASSENGER SIDE OF VEHICLE. UNABLE TO LOCK OR UNLOCK DRIVER DOOR, IF LOCKED ITS NOT ALLOWING ME TO ENTER THE VEHICLE AND HAVE TO ENTER VIA PASSENGER DOOR. AUTO DIM IMPACTS VISABLITY WITH DRIVING AT NIGHT. REAR BACK UP CAMERA IN-OP IS DAMGEROUS IN NUMEROUS ASPECTS. Has the problem been...

What component or system failed or malfunctioned, and is it available for inspection upon request? INTERNAL WATER PUMP/ TIMING CHAINS/ VVT SOLENOIDS/ CAM PHASERS/ CAM SENSORS/ RELATED SEALS How was your safety or the safety of others put at risk? ENGINE FAILURE - SUDDEN STOP OF VEHICLE Has the problem been reproduced or confirmed by a dealer or independent service center? YES, IS AWARE AND HAS ACKNOWLEDGED VIA SERVICE AND TECH BULLETINS THAT THIS IS A KNOWN AND REPEATED ISSUE. ISSUE IS KNOWN AND COMMON WITH ALL 3.7L AND 3.5L FORD ENGINES. MANUFACTURER HAS HAD PETTY AND CLASS ACTION SUITS RELATED TO THIS FAILURE AND IS NOT TAKING ANY ACTION TO REMEDY ASIDE FROM A "EXTENDED WARRANTY" FOR CERTIAN COUNTRIES BUT SAID WARRANTY DOES NOT HELP THOSE WHO PURCHASED VEHICLES USED AND HAVE NO VEHICLE HISTORY TO SEE IF THE "SERVICE INTERVALS" WERE MET LEAVING THOUSANDS OF OWNERS WITH REPAIR BILLS THAT COST AT MINIMUM OVER FOUR THOUSAND DOLLARS. Has the vehicle or component been inspected by the...

The contact owns a 2013 Ford Flex. The contact stated that while driving at an undisclosed speed, the steering wheel seized, with the power steering fault warning light illuminated. The vehicle was restarted; however, the failure reoccurred, and the steering wheel became difficult to turn. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the steering rack and steering angle and torque sensors had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and several cases were filed. The failure mileage was approximately 140,000.

The contact owns a 2013 Ford Flex. The vehicle was taken to a dealer for a recall repair. The contact stated the dealer declined to perform the recall repair because the vehicle was unable to be started. The contact received notification of NHTSA Campaign Number: 20V072000 (SUSPENSION). The vehicle was currently at the dealer. The vehicle was not repaired. The manufacturer was not made aware of the issue. The failure mileage was 127,000.

On Sunday, February 22, 2026, I was driving my 2013 Ford Flex with the driver’s seat heater activated. After a period of use, I began to notice an unusual electrical burning smell inside the vehicle. There were no dashboard warning lights or system alerts. I turned the seat heater off immediately once I detected the smell. I did not initially notice an injury at that time. The following day, I experienced significant pain and discovered burns on my buttocks in the area consistent with seat contact. I sought medical evaluation three days later and was diagnosed with second- to third-degree burns. Prescription treatment was provided. The vehicle has not yet been inspected for the cause of the overheating or odor. Based on the location and pattern of injury, and the timing of the electrical smell while the heated seat was activated, the burn appears to have resulted from a malfunction of the seat heating element.