2018 Hyundai Tucson Complaints

My car had a lot of trouble accelerating it’s delayed

The engine has been consuming oil, where we were adding at least a quart of oil between oil changes. We noticed the vehicle would shake like it was going to die while idling at a stop light or in a drive through. Recently my husband was driving home from work on a busy highway and the vehicles check engine light started blinking on and off. He pulled over and had the vehicle towed. The oil consumption made the vehicle throw a rod and damage the engine. Now we are needing to replace the engine.

Incident Summary: On 07/16/2026, my 2018 Hyundai Tucson experienced a severe engine failure resulting in sudden knocking sound from engine and stopped in middle of road. This sudden failure while operating the vehicle created an immediate safety risk on the roadway. ​The vehicle was taken to Rick case Hyundai on 07/22/2026 , where diagnostics confirmed on 07/24/2026 internal engine damage tied to connecting rod bearing wear—a known, widespread safety hazard affecting Hyundai 2.0L Nu GDI engines. ​Reason for Complaint: Hyundai Motor America denied warranty coverage and engine replacement, claiming that Service Campaign 966 / Knock Sensor Detection System (KSDS) software had not been installed prior to the failure. ​The KSDS update is a software monitoring/warning tool, not a mechanical fix or routine maintenance requirement. Missing a software patch does not cause physical connecting rod bearing failure. Hyundai is using missing software updates to systematically deny coverage for know...

While driving my 2018 Hyundai Tucson Limited 1.6L Turbo with the 7-speed EcoShift dual clutch transmission (DCT), the vehicle has repeatedly failed to engage and hold gears, resulting in loss of motive power in traffic. Diagnostic scanning retrieved codes P074B (Unable to Engage Gear 3), P074B71 (Unable to Select 3rd Gear), P074B07 (Gear Dropped Out of 3rd Gear), P092177 (1st Gear System Referencing Failure), and P0921 (Gear Shift Forward Actuator Circuit Range/Performance). A Hyundai dealer diagnosed the failure as requiring transmission replacement at approximately 93,000 miles. This is the same 7-speed DCT and the same failure mode addressed by NHTSA Campaign 16V628000 (Hyundai Recall 149) and Hyundai Service Campaign T1B, which covered 2016–2017 Tucson vehicles but excluded the 2018 model year despite using the same transmission. Hyundai has acknowledged this defect in 2018 vehicles through TSB 21-AT-014H and TSB 22-AT-007H, which prescribe a TCU software update, but issued these a...

Car shaking, oil is burning , and drive hard. Engine and, oil light is now appearing.