-
Fuel/propulsion System
07/08/2026
Fuel pump and module failure. Driving on the highway at 70 miles an hour and the fuel pump failed. Causing me to have zero acceleration. Thus losing speed rapidly in the center lane. No warning lights were present before or after. One previous symptom of a crank no start. Dealership was able to replicate the crank no start situation. Resulting in the problem being a fuel pump failure and module needing replaced, at 83,000 miles on the vehicle. Though I know normal wear and tear can and does happen, there was no warning. And losing engine power at high speeds on a highway is unsafe.
-
Structure
05/28/2026
This recall has been unresolved for approximately two years. Recently, while traveling at highway speeds, the A-pillar trim detached from my vehicle and flew off, striking a vehicle behind me. Fortunately, no accident occurred, but the situation was extremely dangerous and could have resulted in serious injuries or property damage. This is precisely the type of incident the recall was intended to prevent. I have reached out to my local dealership numerous times and am told that Ford has no parts available. This is not acceptable and Ford is not handling this recall in a timely fashion.
-
Structure
04/25/2026
The contact owns a 2019 Ford Explorer. The contact stated that while driving, Panel on the driver side door, keyless pad became completely detached. The vehicle was taken to a dealer where it was diagnosed as not being fully secured and was replaced. The panel blew the fuses and affected the liftgate on the vehicle and additional repairs, latch replacement on the liftgate had to be completed. The manufacturer was notified of the issue. The approximate failure mileage 47,000.
-
Steering
05/27/2026
While my granddaughter was driving our 2019 Ford Explorer, the steering effort suddenly increased without warning, as if the electric power steering assist stopped functioning. She was traveling at approximately 45 mph on a public road and was unable to steer normally. The sudden loss of assist caused her to nearly leave her lane and almost resulted in a collision. This vehicle uses an electric‑assist rack‑and‑pinion steering system. There were no warning lights or messages before or during the event. Road conditions were dry. After the incident, steering remained abnormally heavy/intermittent. It isn't as though it mimics an old school vehicle without power steering, where it simply requires a good deal of strength. With this situation, if you work hard to make a correction, the car suddenly pulls further quickly in that direction, or in the opposite direction in a very jerky manner. The failure occurred without any prior symptoms and created an immediate loss‑of‑control hazard, esp...
-
Power Train
02/28/2025
I had my transmission replaced in California on Feb 2025. Had failure issues and took it to ford, they found an issue with the torque converter and replaced 7 months after the new transmission, it was cleaned out for debris and contamination. Early this May took it in again for the vehicle violently shaking, the ford Mechanic before inspecting immediately knew what transmission I had and knew what issue was, said all the 6F35 transmissions are failing. Took it to my local ford dealership who confirmed that the whole transmissions needs to be replaced again. Less than 20k miles on it. Of course this transmission had a law suit filed which was dismissed. Frustrating because it is clearly a known issue. I am currently #10 on the national waitlist for a new transmission. I am expected to be without a vehicle for months.
