2011 Ford Escape Complaints

I have a 2011 Ford Escape AWD 3.0 engine. I took it for NY state inspection and it fails due the right side front subframe is rusted and unsafe. Ford has a recall on models up to 2004 but this vehicle has the same issue of the A/C draining on it causing the rust. I have been an auto tech for over 48 years, retired now, and strongly feel this should be a major concern and covered at least 50% by Ford. This design flaw and the fact that I live in a state that uses salt in the winter on the roads, I feel there is nothing I could have done to prevent this from happening.

The contact owns a 2011 Ford Escape. The contact stated that while operating the vehicle, the vehicle lost power steering functionality, and the steering wheel became difficult to turn in either direction. The vehicle was taken to the local mechanic, who diagnosed that the steering torque sensor had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 14V284000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 150,000.

I went for an oil change and my mechanic found that the subframe/cross member assembly was almost rusted through. Very dangerous. Needs to be replaced. Found out this is very common with the Ford Escape model of these years. Will cost thousands to repair.

The rear hatch clicks like it wants to open but doesn't release the latch to open it and I can't get to the place to release an lower the spare tire which is safety concern to me. Also the driver side seat belt casing broke and doesn't release every time you push button to unlatch it which can cause serious problems if in an accident I had a individual garage guy inspect an said he had replaced several latch mechanisms in the hatch for several escape owners i can't afford to have it replaced at this time. If we're to have a flat in extreme heat or extremely cold weather it can cause heat stroke or hypothermia. There were no warning signs one day wouldn't open. An seatbelt wouldn't release one day until pushed so hard the casing broke off an could push clip inside

The steering shaft torque sensor unexpectedly malfunctioned while driving resulting in a loss of steering. There was no indication that this would happen, no check engine light was on, and no symptoms prior to the incident. The vehicle is undrivable due to a lack of steering and was diagnosed by an independent garage. The steering shaft torque sensor is recalled for other 2010 Ford Escapes, but not this one.