-
Fuel/propulsion System
08/21/2023
The High-pressure Fuel pump failed during a routine drive at approximately 1500 RPMs. This caused an immediate loss of power while in traffic. Manage to limp the car to the nearest gas station in which the car finally died and would not start. Had to call for a tow truck. This immediate loss of power could have cause myself and my daughter to get into an accident. Luckily, we were not on a major highway doing 65+ MPH, which could have been a lot worse. The vehicle flashed a MIL light or flashing glow plug light at the time of the incident. The car did not show any signs of possible failure beforehand. This same issue has been recalled by Fiat-Chrysler on their Heavy-Duty Ram pickup trucks with 6.7L Cummins due to catastrophic failure of the CP4 fuel pump.
-
Electrical System
11/18/2022
Fuse F16 (30A) in the engine fuse plate, melted instead of breaking - causing half of the cars lights to stop functioning including turn signals and brake lights. Cannot be fixed with replacing the fuse as it was never tripped but instead the whole fuse plate needs to be replaced. No warning lights preceded the event, all lights went out while driving. VW dealership requires a new plate to be put in with no explanation of what caused the melt and no guarantee that it won’t happen again. Multiple online forums suggest a similar finding, and even other models have tickets for recalls (same problem, same part) but not the 2011 Golf TDI.
-
Electrical System, exterior Lighting
01/15/2022
The wire from the alternator to the underhood fuse block is not thick enough to handle the current from the stock alternator. This causes the wire to get too hot melting the fuse block at the 30 amp fuse causing headlight issues.
-
Electrical System, engine
05/01/2022
Electrical Short caused catastrophic fire in engine compartment, suspected issue is a water leak due to faulty manufacturing. Leak was noted by Volkswagen repair facility and was to be inspected and repaired within 30 days
-
Engine, fuel/propulsion System
12/23/2021
Driving on interstate at 70 mph with cruise control on when car suddenly slowed and warning lights began flashing. I slowed to 60 mph and within a minute the engine shut off and was almost rear ended by a semi truck before I could get to the shoulder of the highway. Engine would not restart and I was stranded on the highway. Had to have the vehicle towed by AAA back to my home. Used my Ross-Tech VCDS scanning tool to troubleshoot and found codes: P0087 (fuel rail system pressure too low), P020 (cylinders 1-4 injection timing), P1004-P1007 (torque difference cylinders 1-4). Examined fuel filter and fuel metering valve and found metal chips and particles in both places. Based on this evidence, the high pressure fuel pump has likely failed. My safety was put at risk when the failure occurred due to the sudden loss of power and subsequent near collision with a truck. Additionally I was in danger of being hit by other vehicles as I sat on the shoulder of the highway waiting for a tow...
