2015 Mazda Mazda6 Complaints

Premature sub-frame corrosion front and rear due to road salt and poor part finishing affecting most underbody components. All exposed stamped structural sub-frame components rusting at weld locations. Critical parts with severe rust and imminent failure: Lower Rear Control Arms (Left & Right), Rear Stabilizer Links (Left & Right). Potentially hazardous corrosion on Front Lower Control Arms. Rear Cross-member rusting at all weld locations. Cat. Sensor Protector Shield has disintegrated. Available for inspection upon request. Failure has not happened yet, but when it does vehicle control will be compromised. Dealer identified problems 12/18/21 and recommended/quoted repair. Vehicle inspected by dealer only. No indicator warnings exist for structural corrosion.

Mazda recalled the problem with the emergency brake(recall1217F) .The dealership did some cosmetic fix that did not prevent it from happening. The emergency brake when applied activated a lever when the brake is released the lever returns to it's original position.The recall was supposed to address the corrosion on the lever shaft that causes it to stick and not release the brake.

WHILE DRIVING MY 2015 MAZDA 6 GT, WITH 40,0000 MILES ON IT, ON A MAIN LOCAL ROAD, WITH A MAX SPEED LIMIT REQUIREMENT OF 45 MPH, I ATTEMPTED TO TURN INTO THE RIGHT TURN LANE AT A SPEED OF APPROX 35 MPH, WHILE LIGHTLY DEPRESSING THE BRAKE. AS I BEGAN TO TURN, THE STEERING JUST LOCKED UP, AND THE POWER STEERING STOPPED WORKING. A FEW DASHBOARD LIGHTS ALSO CAME ON AT THE SAME TIME.. ONE SAID POWER STEERING MALFUNCTION, THE OTHER WAS A RED HAZARD SYMBOL, AND I DON'T SPECIFICALLY RECALL THE OTHER. I FINALLY SHUT THE CAR OFF AFTER A FEW MINUTES. WHEN I RESTARTED THE CAR, AFTER SEVERAL SECONDS THE WHEEL REGAINED MOBILITY AND THE DASHBOARD LIGHTS WENT OFF. I CAREFULLY AND SLOWLY DROVE MY CAR HOME, APRROX 2 MILES FROM WHERE IT HAPPENED. I HAVEN'T DRIVEN THE CAR SINCE, DUE TO FEAR OF IT HAPPENING AGAIN. I WAS ALMOST REAR ENDED TWICE WHEN IT HAPPENED.

AUDIBLE WHINE FROM TRANSMISSION WHEN IN MOTION. I CAN'T RECREATE THE NOISE WHEN STOPPED OR IN NEUTRAL AND CAN BE HEARD WHEN IN DRIVING AND PICKING UP SPEED.

MY VEHICLE HAS HAD STRANGE GRUNTING, SQUEAKING, POPPING NOISES COMING FROM THE FRONTEND, PARTICULARLY THE DRIVERS SIDE. IT HAS HAD THIS ISSUE SINCE I BOUGHT THE CAR IN JUNE 2017. THE NOISE SEEMS TO BE WORSE WHEN DRIVING OVER SMALL BUMPS. IT'S VERY NOTICEABLE WHEN I BACK OUT OF MY DRIVEWAY. I HAVE ADDRESSED THIS ISSUE WITH THE DEALERSHIP I PURCHASED MY CAR FROM. THEY CAN'T DUPLICATE. I HAVE RESEARCHED THIS EXACT ISSUE AND FOUND THERE IS A TSB FOR THE SUSPENSION ISSUE I'M DESCRIBING. I'M JUST GETTING WORRIED ABOUT MY SAFETY. I'M AFRAID SOMETHING WILL FAIL AND I FEEL IT'S THE MANUFACTURERS RESPONSIBILITY TO CORRECT THIS UNSAFE ISSUE WITH THE SUSPENSION THAT AFFECTING MANY OTHER MAZDA 6 VEHICLES.