2019 Mazda CX-5 Complaints

The engine has an oil leak from the head. It is a common problem with this year and make. It is a manufacturer's defect called a porous head where oil leaks through the casting not a seal. I've already spent $2000 to repair but still leaks. Oil leaks onto the exhaust and smokes causing fumes in the inside of the car and can be a fire hazard. Mazda is well aware of the problem but has yet to address it.

We began occasionally smelling an acrid smell, but didn't think much of it due to lack of visible leaks or warning lights. During a routine oil change at the mazda dealer, we asked about the smell, and the tech almost immediately found the issue, saying he had seen it a few times before. The oil is leaking from the head down onto the manifold due to what seems to be a recurring defective casting issue. quote from mazda dealer service department "During the vehicle's inspection, found oil leaking from the engine. A further inspection found the oil to be leaking from behind the cylinder head near the exhaust manifold. oil is leaking through the casting of the cylinder head it appears. will recommend replacing the cylinder head due to the oil leak."

Cylinder block cracked on back side of engine. This crack leaks oil onto the exhaust manifold. Condition Confirmed by Mazda dealer. Oil burns on the exhaust filling the cabin with smoke impairing the driver. Also a high risk of combustion in the engine compartment Inspection report and pictures available. No sign or warning of issue. Crack happened on a daily drive to work. No engine lights noise or smell until head suddenly cracked causing a large oil leak. Mazda has an internal TSB 01-002/23 admitting that these cars in this year range have a manufacturer defect in the block

On May 11th I was driving my 2019 Mazda CX-5 with approximately 35,000 miles when my cabin filled with the smell of gasoline. The smell became overwhelming within minutes, causing concern for my safety and the safety of other drivers. I immediately drove to the closest auto repair/body shop for an emergency inspection. Upon inspection, the technicians discovered there was a "crack at rear cylinder head and leaking oil excessively. Oil is leaking on to hot exhaust manifold....car is not safe to drive since oil leak is excessive". I was advised that this must be a manufacturer defect as you should not see this issue at such low mileage. The vehicle was then towed to the nearest Mazda dealership/service center, where a cracked rear cylinder head was diagnosed and confirmed. I was informed that continued operation of the vehicle could have resulted in catastrophic engine failure, engine seizure, fire risk from leaking oil contacting hot engine components, or sudden loss of power whil...

My 2019 Mazda CX-5 (equipped with the 2.5L naturally aspirated SkyActiv-G engine with cylinder deactivation) has experienced a severe structural failure resulting in a cracked engine cylinder head. This casting defect allows pressurized motor oil to leak continuously from the cylinder head down onto the hot engine block and nearby exhaust components. This has led to the following severe safety risks: engine oil is leaking onto the exhaust manifold and creates an extreme risk of engine compartment fire when the vehicle is in motion; sudden loss of oil pressure or complete structural failure of the cylinder head can cause the engine to stall or seize unexpectedly without warning, completely disabling the vehicle in live traffic and creating an imminent crash hazard; and dropping oil levels and leaking fluids burning against the engine produce strong smoke and chemical odors that enter the cabin, which can cause driver distraction and severely limiting visibility if smoke escapes throug...