2018 Mazda CX-5 Complaints

The contact owns a 2018 Mazda CX-5. The contact stated that while his wife was driving at an undisclosed speed, there was smoke coming from under the hood. No warning light was illuminated. The contact's wife pulled over and discovered that there was oil leaking onto the ground. The vehicle was towed to the dealer, who determined that the #5 and #7 cylinder heads were cracked and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

I am writing to formally document a significant engine failure on my 2018 Mazda CX-5 Grand Touring (VIN: [XXX], License: [XXX], Odometer: 78,159 miles). The vehicle began exhibiting visible smoke from under the hood and severe oil leakage — oil was actively pooling beneath the car and leaving a trail. Upon inspection by Cal West Auto Center (San Marcos, CA), the vehicle was diagnosed with a leaking cylinder head gasket requiring full cylinder head removal and replacement. I am aware that Mazda issued Technical Service Bulletin TSB #SA-031-21 specifically addressing a cylinder head casting defect in 2018–2019 CX-5 models equipped with the 2.5L Skyactiv-G engine with cylinder deactivation — the exact configuration of my vehicle. This is a documented manufacturing defect, not normal wear and tear, and the repair estimate I have received is $4,800.84. Given that this failure is tied to a known defect acknowledged by Mazda, I am requesting that Mazda Motor America cover the cost of this...

Check engine light on when read it comes back with P0171 code

The contact owns a 2018 Mazda CX-5. The contact stated that white smoke was coming from the engine compartment whenever the vehicle reached normal operating temperature. The contact stated that smoke entered the passenger’s side compartment through the air vents and was coming from underneath the hood. The contact stated that there was a burning odor coming from the engine compartment due to an oil leakage. The smoke impaired visibility while driving. The most recent failure had occurred while driving approximately 35 MPH on a city roadway. The vehicle was driven to an independent mechanic to be diagnosed, and then to the dealer for further inspection. The independent mechanic diagnosed the vehicle with a cracked cylinder head and recommended that the vehicle be taken to the dealer for additional diagnostic tests. The dealer diagnosed the cylinder head as porous and informed the contact that the cylinder head needed to be replaced. The manufacturer was notified and informed the contact...

My Mazda 2018, CX-5, Grand Touring, was diagnosed with a cracked cylinder head at 64,599 miles. This issue could posed a safety hazard for not only us but others on the road by: *Engine Failure / Sudden Loss of Power-A crack allows coolant and oil to mix or leak, leading to overheating and potential catastrophic engine seizure. A seized engine can cause sudden, unexpected loss of power — especially dangerous at highway speeds or during lane changes/merges. *Oil and Coolant on the Road-Leaking fluids drip onto the roadway, creating slick surfaces for motorcyclists and other vehicles — similar to a spilled oil hazard. This is especially dangerous on curves and in wet conditions. *White Smoke / Steam Billowing from Exhaust-When coolant enters the combustion chamber, it burns off as thick white smoke. This can instantly reduce visibility for drivers behind the vehicle, potentially causing rear-end collisions. *Fire Risk-If oil leaks onto hot exhaust manifolds or engine components, it ca...