2003 Mazda B-Series Complaints

SUDDEN AND UNEXPECTED LOSS OF CLUTCH FLUID RENDERING VEHICLE INOPERABLE (LOSS OF CONTROL TO GO FORWARD AND GET OUT OF THE WAY) DUE TO AN INABILITY TO SHIFT GEARS. LEAK AT CLUTCH SLAVE CYLINDER IS SUSPECT. FOUND MYSELF TO BE A "SITTING DUCK" AT A TRAFFIC INTERSECTION ALTHOUGH FORTUNATELY, NO ACCIDENT OCCURRED. *TR

I WAS DRIVING INTO THE MOUNTAINS OF NC FROM SC. SMELLED SMOKE. REALIZED IT WAS COMING FROM IN BETWEEN TRUCK CAB AND BED. IT WAS VERY DIFFICULT TO PUT OUT FIRE AS IT HAD STARTED TO MELT THE PLASTIC BED LINER AND PLASTIC GAS TANK. FIRE WAS CAUSED BY A 2 FOOT BY 2 FOOT PIECE OF CARDBOARD THAT HAD FALLEN DOWN BETWEEN BED AND CAB. IT WAS RESTING ON THE GAS TANK AND LEANING TO THE SIDE ON TOP OF THE MUFFLER. I ASSUME IT CAUGHT FIRE AS WE TRAVELED SLOWLY UP THE WINDING ROAD. (HWY 276) THERE IS NO SHIELD OVER THE MUFFLER. WHEN THE TANK WAS REPLACED IT WAS REPORTED TO ME THAT THE FIRE HAD MELTED THE TOP OF THE FUEL PUMP AND HAD EXPOSED A HOLE IN THE GAS TANK. I BELIEVE THIS A VERY SERIOUS PROBLEM THAT NEEDS TO BE DEALT WITH BY MAZDA. *JB

I WAS IN AN ACCIDENT AND I WAS HIT FROM BEHIND AND MY CAR WENT FLYING INTO THE GUARD RAIL AT ABOUT 35 MILES PER HOUR HEAD ON AND MY AIR BAGS DID NOT DEPLOY. I WAS SENT TO THE HOSPITAL. *NM

'03 B-3000 DUAL SPORT... 41,XXX MILES... MANUAL TRANSMISSION GRINDS WHEN SHIFTING BETWEEN 2ND AND 3RD GEAR, AND GRINDS AGAIN, BETWEEN 3RD AND 4TH GEAR, THIS HAPPENING AFTER A 10 HOUR TRIP ON THE HIGHWAY AT SPEEDS AROUND 70-75 MPH. *NM

12/07/05 ENGINE DIED ON 4 LANE HWY, 42 MILES FROM HOME IN RUSH HOUR TRAFFIC. TOWED TO DEALER, WHO TWO DAYS LATER STATED PROBLEM WAS FUEL PUMP RELAY, AND IT WAS FIXED. 01/25/05 TRUCK DIED IN INTERSECTION AT 4:30 P.M. HUSBAND TAPED WIRES AND WIRE-TIED CONNECTOR TO RELAY. DEALER ORDERED FUEL CUT-OFF SWITCH 01/27/05 AND DID NOT INSTALL UNTIL 02/03/06, BECAUSE WAITING FOR PART. DEALER RELOCATED THE RELAY FROM FLOOR BOARD TO BEHIND THE PASSENGER KICK PANEL AND WIRE-TIED THE CONNECTOR TO THE RELAY AND SWORE THIS WOULD SOLVE PROBLEM. ON 02/10/06 THE ENGINE DIED AT 1:00 P.M., 50 MILES FROM HOME. BECAUSE OF PREVIOUS HISTORY, I MANAGED TO RESET AND CONTINUE HOME AND LEFT MESSAGE WITH SERVICE MANAGER. MY HUSBAND DECIDED TO INSPECT SITUATION, AND DISCOVERED THE WIRE CONNECTOR THAT PLUGS INTO THE RELAY IS BROKEN AND IS THE CAUSE FOR FAILURE. WE BELIEVE THIS DAMAGE WAS PROBABLY CAUSED BY THE ORIGINAL LOCATION OF ASSEMBLY UNDERNEATH PASSENGER FLOOR MAT. PRESENTLY AWAITING CALL BACK FROM SERVICE MANAGE...