-
Tires
03/08/2020
ON MARCH 8, 2020 WHILE DRIVING AT 75 MPH ON INTERSTATE 75, THE RIGHT REAR (RR) TIRE ON MY 2004 JEEP WRANGLER BLEW OUT. THE TIRES WERE PURCHASED AT SAM'S CLUB IN MAY 2018. THE VEHICLE HAD A MATCHING SET OF TIRES ALL PURCHASED AT THE SAME TIME (MAY 18) - BF GOODRICH ALL TERRAIN TA KO2. SIZE 31 X 10.5 R15. THE MILEAGE ON THE TIRE AT TIME OF BLOW OUT WAS ONLY 16,386 MILES. IT IS VERY CLEAR FROM PHOTOGRAPHS THAT REAR TIRE TREAD SEPARATED FROM THE SIDEWALL. WEATHER CONDITIONS AT TIME OF TIRE FAILURE WERE EXCELLENT - CLEAR, SUNNY, 57 DEG F. ROADS WERE CLEAR AND DRY. TIRE PRESSURE FOR REMAINING 3 TIRES WAS CHECKED IMMEDIATELY AFTER BLOW OUT OF RR, AND ALL 3 TIRES WERE FOUND TO BE SAME PRESSURE (35 PSI). THE TIRE WAS MARKED DOT BF60_AT11_1118. I AM AN AUTOMOTIVE ENGINEER WITH +30 YEARS OF EXPERIENCE IN AUTOMOTIVE DRIVELINE. THE WAY THE TREAD SEPARATED CLEANLY FOR FULL 360 DEG FROM SIDEWALL ON FRONT OF TIRE CLEARLY LEAVES ME BELIEVING THERE IS A MANUFACTURING OR DESIGN DE...
-
Steering, seat Belts
01/30/2018
I HAVE A RIGHT HAND DRIVE 2004 JEEP WRANGLER. THE RIGHT SEAT BELT LATCH IS ALWAYS STICKING CAUSING MY SEAT BELT TO COME LOOSE. THE STEERING WHEEL STARTS SHAKING VIOLENTLY WHEN REACHING SPEEDS ABOVE 50 MPH,IF YOU HIT A BUMP, OR IF IT'S WINDY OR AN 18 WHEELER PASSES YOU ON HIGHWAY, THE JEEP WILL ROCK SIDE TO SIDE LIKE IT'S GOING TO TURN OVER. IT'S VERY HARD TO CONTROL THE VEHICLE. I HAVE CHILDREN TO HAUL AROUND.
-
Seat Belts
08/01/2019
PASSENGER FRONT SEAT BELT JAMMED IN 2004 JEEP RUBICON.
-
Steering, service Brakes
06/20/2019
TL* THE CONTACT OWNED A 2004 JEEP WRANGLER. THE CONTACT STATED THAT WHILE EXITING HER DRIVEWAY CARPORT GOING 10 MPH, WITHOUT WARNING THE VEHICLE ACCELERATED AND THE CONTACT COULD NOT CONTROL THE STEERING WHEEL WHICH SEIZED. THE CONTACT ATTEMPTED TO DEPRESS THE BRAKES WHICH FAILED CAUSING, THE CONTACT TO CRASH INTO THE CARPORTS POLE ALLOWING THE VEHICLE TO COME TO A COMPLETE STOP. NO EMERGENCY BRAKE WAS APPLIED. NO INJURIES, NO POLICE REPORT FILED, NO MEDICAL ATTENTION, NO DAMAGE'S TO THE VEHICLE, THE DEALER WAS NOT CONTACTED, AND NO DIAGNOSTIC TEST WAS PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
-
Steering, suspension
11/01/2010
WHEN THE WRANGLER REACHES APPROXIMATELY 55 MPH, IT BEGINS TO VIOLENTLY (AND TERRIFYINGLY) SHAKE UNCONTROLLABLY. IT MAKES IT DIFFICULT TO MAINTAIN ANY CONTROL OF THE VEHICLE, AND WE HAVE HAD SEVERAL NEAR MISSES, BARELY AVOIDING ACCIDENTS. WE HAVE REPORTED THIS FOR *YEARS* TO OUR AUTO REPAIR AND TIRE COMPANIES, HAD SEVERAL THINGS DONE IN A DESPERATE ATTEMPT TO REMEDY IT, INCLUDING 2 SETS OF TIRES, WITH NO SUCCESS. WITH REPORTS OF THE "DEATH WOBBLE" NOW BECOMING WIDELY KNOWN, WE INSTANTLY KNEW THAT WE WERE NOT ALONE, AND THAT THIS IS A WIDESPREAD ISSUE THAT JEEP NEEDS TO ADDRESS. THIS IS A HUGE SAFETY ISSUE.
