-
Unknown Or Other
06/01/2026
The heat from the sun is making the leather dash warp and flipping up in the drivers view. It is also coming apart behind the media control screen.
-
Fuel/propulsion System
06/11/2026
On [XXX], at approximately [XXX] PM, my 2022 Ford Explorer suddenly lost power while driving in the left lane of [XXX] in Emporia, VA, at 70 MPH (the posted speed limit), with my [XXX] daughter. My vehicle shuddered and started to decrease in speed. I was able to maneuver safely to the shoulder, and my Explorer became inoperable requiring roadside assistance. My daughter and I remained on [XXX] for several hours due to delayed tow service availability. My Explorer has been at Battlefield Ford in Culpeper, VA since June 19, 2026, and is available for inspection upon request. Battlefield has confirmed the low-pressure fuel pump failure, confirmed this is subject to Safety Recall 25S75 (NHTSA Recall 25V455), and there is no remedy available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
-
Electrical System, back Over Prevention
06/18/2026
While driving, parking, or doing any function of the vehicle, the screen will intermittently switch from the cameras being used to the on board navigation and start routing the vehicle to random locations, or it may blank out completely. It has also frozen in place and will not display reverse cameras, show proximity sensors, or anything.
-
Fuel System, Gasoline
06/29/2026
The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
-
Unknown Or Other
06/13/2026
When getting off the interstate at an exit, my husband pushed the brakes to stop and our vehicle completely shut off. The hazard lights would not work and it would not restart. We were at a very busy exit and we had our 2 children in the car with us. We could not get it jumped or anything and were 2.5 hours away from home. The fact that we couldn't even use hazards to warn other cars was scary, as it was a very busy exit. Our car was towed to the shop and we were just told that the battery mounted mega fuses had melted and that is what caused the car to completely shut down. This is not covered by warranty and we recently had our battery checked to make sure we did not need a new battery as we figured it was getting close to time. Apparently the fuses are not typically inspected. If this is the case, why would this not be covered by a warranty? This put us in a very dangerous situation. As it could have happened on the interstate if we would have needed to brake. The police di...
