-
Engine And Engine Cooling, vehicle Speed Control
02/11/2012
MY TENANT'S VEHICLE - A 1994 FORD EXPLORER - SPONTANEOUSLY CAUGHT FIRE WHILE PARKED IN MY PROPERTY'S GARAGE IN THE MIDDLE OF THE NIGHT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FLAMES AND DETERMINED THAT THE CAUSE OF THE FIRE WAS THE CAR ITSELF - LIKELY A FAULTY CRUISE CONTROL VALVE ACCORDING TO THEM. THE INSURANCE COMPANY WILL CONDUCT ITS OWN INVESTIGATION. *TR
-
Engine And Engine Cooling, vehicle Speed Control
07/11/2011
I WAS SITTING AT A STOP LIGHT ALL OF A SUDDEN THE TRUCK ACCELERATED FORWARD. THE NEXT EVENT I WAS TRAVELING ABOUT 40 MILES AN HOUR AND THE TRUCK ACCELERATED OUT OF CONTROL AND I WAS UNABLE TO STOP IT, THE BRAKES WOULDN'T STOP IT, FINALLY I TURNED THE KEY OFF AND IT SHUT DOWN. IT'S BEEN HAPPENING ON AND OFF SINCE THEN. IT DOESN'T HAPPEN ALL THE TIME, BUT, I NEVER KNOW WHEN IT WILL HAPPEN AGAIN. I CONTACTED FORD SEVERAL TIMES ABOUT THIS PROBLEM AND THEY TOLD ME IT COULD BE ALOT OF DIFFERENT REASONS, THEY NAMED OFF SOME PARTS AND I REPLACED ALOT OF THEM AND AM STILL HAVING THE SAME PROBLEM. THEY DID SAY THEY HAVE HEARD OF OTHER PEOPLE HAVING THE SAME PROBLEMS, BUT THEY WERE NOT ALL FOR THE SAME REASONS. *TR
-
Fuel System, Gasoline, vehicle Speed Control
09/26/2011
INVESTIGATION OF A MOTOR VEHICLE TRAFFIC COLLISION REVEALED THAT THE ACCELERATOR PEDAL ON 1994 FORD EXPLORER (UNKNOWN MILES) MAY BECOME STUCK IN THE "FULL OPEN THROTTLE" POSITION. CONDITION OCCURS WHEN THE ACCELERATOR PEDAL ARM WEARS A SLIT IN THE RUBBER SOUND/HEAT INSLUATION ON THE FLOOR BOARD. AFTER THAT OCCURS, WHEN THE ACCELERATOR IS FULLY DEPRESSED, THE ARM CAN BECOME STUCK IN THE RUBBER. CONDITION WAS DISCOVERED DURING INVESTIGATION OF A FATAL CRASH. AFTER THE CONDITION WAS DISCOVERED, IT COULD BE EASILY AND REPEATEDLY REPLICATED. NOTE: FATALITY OCCURRED WHEN THE DRIVER, FOR UNKNOWN REASONS, EXITED THE VEHICLE WHILE IT WAS STILL IN MOTION AT UNKNOWN SPEED. DRIVER DIED UPON IMPACT WITH ROAD. VEHICLE CONTINUED OFF ROAD AND CAME TO REST, MOSTLY UNDAMAGED, IN A FIELD WELL OFF ROAD SURFACE. *TT
-
Structure, vehicle Speed Control, tires
01/26/2011
WHILE DRIVING I TURNED ON AIR CONDITIONER AND IMMEDIATELY LIGHT SMOKE BEGAN OUT OF AIR CONDITIONING VENTS AND THEN THE NEXT MOMENT THE SMOKE WAS EXTREMELY HEAVY OUT OF THE VENTS AND THEN VISIBLE FIRE UNDERNEATH FRONT PASSENGER SIDE DASHBOARD. I IMMEDIATELY PULLED THE VEHICLE OFF THE SIDE OF THE ROAD AND EXITED, 10 MINUTES LATER IT WAS FULLY ENGULFED IN FLAMES. *LN
-
Electrical System
01/05/2011
1994 FORD EXPLORER HAD SMOKE COMING OUT OF THE AIR-CONDITIONER VENTS INTO THE PASSENGER COMPARTMENT, SLIGHT AT FIRST, THEN SO HEAVY THAT FORWARD VISIBILITY WAS OBSCURED. AFTER STOPPING THE VEHICLE, A SMALL FIRE WAS SEEN BURNING THE PLASTIC EVAPORATOR COVER WHERE THE BLOWER MOTOR RESISTOR ASSEMBLY IS MOUNTED IN THE EVAPORATOR COVER. SOME SNOW THROWN ON THE FIRE PUT IT OUT. THE BLOWER MOTOR APPEARS TO BE SHORTED OR MAYBE JAMMED FROM ROTATING, CAUSING THE RESISTOR TO GET HOTTER THAN NORMAL, IGNITING THE PLASTIC COVER. MAYBE LEAVES OR OTHER FLAMMABLE DEBRIS CONTACTED THE RESISTOR, BUT I CAN'T TELL AS THE FLAMES BURNED UP ANYTHING IN THE AREA AROUND THE RESISTOR ASSEMBLY. FORTUNATELY, I WAS ABLE TO BRING THE VEHICLE TO A SAFE STOP, IN SPITE OF VERY LIMITED VISIBILITY IN THE HEAVY SMOKE. I WAS ON A SLOW SPEED, LOW TRAFFIC CITY STREET. THE RESULTS WOULD HAVE BEEN MUCH WORSE IF THE FIRE OCCURRED AT HIGHWAY SPEEDS. THE BLOWER MOTOR WILL BE AVAILABLE FOR INSPECTION WHEN I REMOVE...
