2009 Volvo S80 Complaints

The headlight system malfunctioned. It is available for inspection upon request. The low beam failure error occurred, which led to an inspection of the headlight system. The wiring inside the headlight assembly failed. The insulation on bulb wires is crumbling everywhere and causing short circuits from exposed wire conductors. This causes a safety issue because the bulbs stop functioning, impairing visibility of the car, visibility of the road, and disabling motion intent lights like the turn signals. Bare wires touching can also lead to overheating and fires or failures of the headlight electrical system. Humidity may damage the exposed wires and cause bulb failure or wire overheating. The wiring harnesses may also overheat. The wire insulation problem was confirmed by an independent service center on multiple cars of this model.

For the last several years I’ve been complaining about my TPMS ALWAYS reflecting a “Low Tire Pressure “ response. Recently I went in for a oil change but indicated the my tire pressure light was on again. I take the Volvo to a shop I trust. Global AutoWorks in GrandHaven. They took care of my previous owned BMW without any issues. I put in Volvo S80’s recall site and found that there was a recall on 10/07/2010. The vehicle was a private purchase made in January 8, 2018 from the original owner. Upon purchase I made the decision to put new tires on the vehicle to see if that would fix the problem. $1200.00 later and the problem was not resolved. I do not feel that I should pay for safety issue that the company knew about. I spoke to the previous owner and she did not receive a letter from Volvo. The Volvo is in very good condition with low mileage for a 14 year old car. 69,815. Second issue: Seat belt issue. Reason for recall: Volvo car investigations have identified a problem regar...

At night, when a direct strong light (headlight) from behind shines on the car, the BLIS system stop working. The only way to reset the system is to stop and restart the car, instead of turning the system button OFF and then back ON. This is unsafe since when you are on the highway, it is unsafe to do so. A simple fix is a software update that will RESET the system when you turn it OFF and then ON again

The contact owns a 2009 Volvo S80. The contact stated that the seat belt warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the seat belt assembly to be replaced. The vehicle was not repaired but was pending repairs. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V378000 (Seat Belts) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 188,000.

SEVERE SUBFRAME RUST DUE TO THE EXHAUST ON VOLVO S80 V8 BEING TOO CLOSE AND MELTING THE PAINT OFF. CAR IS VERY CLEAN AND WE'LL TAKEN CARE OF. APPEARS TO BE A VERY COMMON PROBLEM ON THE V8 S80S.