2009 Volvo S40 Complaints

TL* THE CONTACT OWNS A 2009 VOLVO S40. WHILE DRIVING APPROXIMATELY 25 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE INDEPENDENTLY DECELERATED AND STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FUEL LINE WAS FRACTURED. THE TRANSMISSION FUEL LINE AND THE TRANSMISSION FLUID WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

TIRE PRESSURE MONITORING SYSTEM (TPMS) FAILURE WHICH ALMOST RESULTED IN A CRASH AT HIGH SPEED. TPMS AIR STEM BROKE WHILE DRIVING. THE TPMS THEN FELL INTO THE TIRE, LEAVING THE AIR STEM HOLE WIDE OPEN, WHICH RESULTED IN RAPID DEFLATION OF THE TIRE. OPERATOR OF THE VEHICLE WAS ABLE TO BARELY KEEP CONTROL OF THE VEHICLE AND BRING IT SAFELY TO A STOP; TIRE WAS COMPLETELY DESTROYED - NOTHING BUT THE WHEEL RIM WAS LEFT. MECHANIC / RECOVERY PERSONNEL WITH TOW TRUCK SAID IT WAS A MINOR MIRACLE THAT AN ACCIDENT/ CRASH WAS AVOIDED. WHEN REPORTED TO VOLVO, NO SUPPORT OR ACTION TAKEN ON THEIR PART. THEN EXPERIENCED A SECOND TPMS FAILURE APPROXIMATELY 7 MONTHS LATER, WHILE DRIVING THE VEHICLE AT 30 MPH ON THE WAY HOME; TIRE WAS FLAT AND MECHANIC SAID TIRE NEEDED TO BE REPLACED AS IT WAS DRIVEN WHILE DEFLATED. AGAIN REPORTED FAILURE TO VOLVO DEALER, AND THIS TIME THEY DID LISTEN TO MY COMPLAINT AS ANOTHER OWNER REPORTED SAME PROBLEM. VOLVO DETERMINED THAT THE TPMS AIR STEM WAS UNABLE TO WITH...

MY WIFE WAS DRIVING HOME FROM A GROCERY STORE 3 MILES AWAY. A QUARTER MILE FROM THE HOUSE SHE NOTICED A BURNING SMELL. SHE THOUGHT IT WAS FROM THE OUTSIDE SINCE BRUSH FIRES ARE COMMON AROUND SOUTH FL. SHE PARKED ONTO OUR DRIVEWAY AND NOTICED SMOKE RISING FROM AROUND THE HOOD. SHE TOOK THE KEY OFF OF THE IGNITION AND THE ENGINE KEPT RUNNING. SHE CALLED THE FIRE DEPARTMENT WHILE A NEIGHBOR HELPED AND OPENED THE HOOD. IMMEDIATELY SMOKE STARTED BILLOWING AND THEY OBSERVED FIRE IN THE ENGINE.TWO FIRE ENGINES SHOWED UP AND CONTAINED THE FIRE BEFORE DOING ANY FURTHER DAMAGE. MOST OF THE VISIBLE DAMAGE IS BETWEEN THE AIR INTAKE MANIFOLD AND THE AIR FILTER HOUSING. ON THAT DRIVE NO WARNING LIGHTS CAME ON, THE CAR RADIO WAS WORKING MY WIFE SAID IT WAS UNEVENTFUL UNTIL THE SHE NOTICED THE SMOKE. MY WIFE WAS SCARED AND STRESSED BEYOND FROM WHAT SHE HAD TO GO THROUGH. THE CARS WARNING SYSTEM DID NOT WORK, THERE WAS SEVERE FAILURE FOR THIS TO HAPPEN ON A 4 YR OLD CAR. I CALLED THE LOCAL VOLVO DEA...

MY WIFE WAS DRIVING HOME FROM A GROCERY STORE 3 MILES AWAY. A QUARTER MILE FROM THE HOUSE SHE NOTICED A BURNING SMELL. SHE THOUGHT IT WAS FROM THE OUTSIDE SINCE BRUSH FIRES ARE COMMON AROUND SOUTH FL. SHE PARKED ONTO OUR DRIVEWAY AND NOTICED SMOKE RISING FROM AROUND THE HOOD. SHE TOOK THE KEY OFF OF THE IGNITION AND THE ENGINE KEPT RUNNING. SHE CALLED THE FIRE DEPARTMENT WHILE A NEIGHBOR HELPED AND OPENED THE HOOD. IMMEDIATELY SMOKE STARTED BILLOWING AND THEY OBSERVED FIRE IN THE ENGINE.TWO FIRE ENGINES SHOWED UP AND CONTAINED THE FIRE BEFORE DOING ANY FURTHER DAMAGE. MOST OF THE VISIBLE DAMAGE IS BETWEEN THE AIR INTAKE MANIFOLD AND THE AIR FILTER HOUSING. ON THAT DRIVE NO WARNING LIGHTS CAME ON, THE CAR RADIO WAS WORKING MY WIFE SAID IT WAS UNEVENTFUL UNTIL THE SHE NOTICED THE SMOKE. MY WIFE WAS SCARED AND STRESSED BEYOND ANYTHING FROM WHAT SHE HAD TO GO THROUGH. THE CARS WARNING SYSTEM DID NOT WORK, THERE WAS SEVERE FAILURE FOR THIS TO HAPPEN. A 4 YR OLD CAR SHOULD NOT HAVE FA...

NEW 2009 VOLVO S40 SEDAN BRAKE FIRE 1. VEHICLE WAS DRIVEN 3 MILES FROM A HIGH SCHOOL PARKING LOT TO THE OWNER'S HOME. 2. THERE WAS A FIRE BETWEEN THE BRAKE PAD AND THE ROTOR IN THE REAR PASSENGER SIDE WHEEL WELL. 3. THE ROTOR, BRAKE CALIPER AND BRAKE PADS WERE REPLACED. *TR