2002 Volvo S40 Complaints

TL* THE CONTACT OWNS A 2002 VOLVO S40. THE CONTACT INQUIRED ABOUT GETTING HER VEHICLE INCLUDED IN AN OPEN RECALL. THE CONTACT STATED THAT THERE WAS A DELAY WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT ALSO STATED THAT SHE OBSERVED A FUEL ODOR INSIDE THE VEHICLE AND SHE WAS CONCERNED OF A FUEL LEAK. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED BEFORE AND AFTER THE FAILURE. THE CONTACT SPECIFICALLY INQUIRED ABOUT NHTSA CAMPAIGN NUMBER: 08V033000 (FUEL SYSTEM, GASOLINE) AND CAMPAIGN NUMBER: 06V137000 (FUEL SYSTEM, GASOLINE). THE CONTACT SCHEDULED AN APPOINTMENT WITH 128 VOLVO CARS (614 NORTH AVE, WAKEFIELD, MA). THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

I WAS DRIVING ON A MAIN ROAD AND MY BRAKES FAILED. IT WAS DETERMINED THAT A BRAKE LINE CORRODED THROUGH. IT APPEARS THAT THE VEHICLE HAS A SINGLE MASTER BRAKE CYLINDER. I ASKED A VOLVO DEALERSHIP ABOUT THIS, AND THEY CONFIRMED TO ME THAT THE MASTER BRAKE CYLINDER IS A SINGLE ONE. IT IS MY UNDERSTANDING THAT IN THE 80'S, ALL VEHICLES SOLD IN THE UNITED STATES WERE TO HAVE A DUAL MASTER BRAKE CYLINDER. *LN

WHILE DRIVING THE RIGHT FRONT AND RIGHT REAR COIL SPRINGS BROKE AND THE FRONT COIL SPRING DAMAGED THE TIRE. DEALER STOCKS THESE EXPENSIVE SPRINGS (BOTH FRONT AND REAR) IN LARGER THAN NORMAL AMOUNTS DUE TO INCIDENCES OF BREAKAGE. I FEEL THAT THIS WAS AN EARLY FAILURE FOR THIS TYPE AND AGE OF VEHICLE AND SHOULD IT HAVE BEEN A A HIGHER SPEED THE INCIDENT COULD HAVE BEEN SEVERE. *TR

TL* THE CONTACT OWNS A 2002 VOLVO S40. THE CONTACT STATED THAT THE BRAKES WERE APPLIED WHILE REVERSING AND THE PEDAL TRAVELED TO THE FLOORBOARD ABNORMALLY. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHERE THE MECHANIC ADVISED THAT THERE WAS A CRACK IN THE MASTER CYLINDER. THE MASTER CYLINDER WAS REPLACED HOWEVER, THE FAILURE RECURRED WHILE IN REVERSE. THE MECHANIC WAS CONTACTED A SECOND TIME WHO ADVISED THE CONTACT OF NHTSA CAMPAIGN ID NUMBER: 04V493000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS) AND INFORMED THE CONTACT TO CALL A DEALER. THE CONTACT CALLED THE DEALER REGARDING THE RECALL BUT THE DEALER STATED THAT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 150,000. UPDATED 10/04/11 *BF THE CONSUMER STATED HE WAS EXPERIENCING PROBLEMS WITH THE BRAKES ON HIS VEHICLE. WHEN HE BACKED OUT OF THE DRIVEWAY, THE BRAKE PEDAL WOULD SINK TO THE FLOOR. WHEN THE VEHICLE WAS PUT IN DRIVE, THE VEHICLE CONTI...

TL*THE CONTACT OWNS A 2002 VOLVO S40. WHILE DRIVING 30 MPH THE CONTACT ENGAGED THE BRAKES WHEN THE VEHICLE IN FRONT OF HER SLOWED DOWN CAUSING A CRASH. THE VEHICLE FAILED TO SLOW DOWN WHEN THE BRAKES WERE APPLIED. THE CONTACT WAS NOT INJURED. A POLICE REPORT WAS FILED. THE CONTACTS VEHICLE HAD FRONT END DAMAGES. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT A LOCAL MECHANIC REPLACED ALL OF THE LEFT FRONT LIGHTS, THE HOOD, THE BUMPER AND THE FENDER. THE FAILURE MILEAGE WAS 104,000 AND THE CURRENT MILEAGE WAS 104,900.