2002 Volvo S40 Complaints

TL* - THE CONTACT OWNS A 2002 VOLVO S40. THE CONTACT STATED THAT THE ENGINEWAS IDLING HIGH. VOLVO STATED THAT THE VEHICLE WAS OPERATING NORMALLY. THE RPM SURGE OCCURRED FREQUENTLY WHEN THE CONTACTWAS DRIVING THE VEHICLE. THE CHECK ENGINE LIGHT CAME ON PERIODICALLY. THERE WAS A RECALL FOR THIS FAILURE ON ALL VOLVO MODELS, BUT NOT FOR THE 240 MODEL. *AK

I BOUGHT A 2002 VOLVO S40 FROM AN INDIVIDUAL IN JANUARY OF 2004. IN A MATTER OF 3 MONTHS IN 2005, I HAD TO REPLACE MY PASSENGER HEADLIGHT 3 DIFFERENT TIMES AND MY DRIVER HEADLIGHT 2 DIFFERENT TIMES. I CALLED THE VOLVO DEALER AND THEY SAID THAT A BULB SHOULD LAST AROUND 2 YEARS. IN THE NEXT MONTH, MY PASSENGER HEADLIGHT WENT OUT AGAIN. I GOT UNDER THE HOOD TO REPLACE IT AS USUAL. WHEN I PULLED THE BLACK PLASTIC PIECE THAT CONTAINS THE MALE PART TO THE WIRE CONNECTION AND ACTS AS THE BULB SOCKET, IT WAS MELTED. IT WAS MELTED TO THE POINT THAT I COULD NOT GET THE BULB OUT UNTIL I USED PLIERS. I TOOK MY CAR TO THE VOLVO DEALER AND THEY SAID THAT I WOULD HAVE TO REPLACE THE WHOLE HEADLIGHT COMPARTMENT. SINCE VOLVO HEADLIGHT COMPARTMENTS ARE "FACTORY SEALED", THEY WOULD NOT BREAK THE SEAL. I WOULD HAVE TO BUY A BRAND NEW ONE @ $500. I DID NOT DO ANYTHING ABOUT IT, BECAUSE I AM NOT PAYING FOR A WHOLE NEW HEADLIGHT COMPARTMENT FOR A PIECE OF PLASTIC THE SIZE OF MY THUMB. TWO DAYS LATER, TH...

I PURCHASED A 2002 VOLVO S40 WHICH FROM THE DEALERSHIP IN JUNE 2002. IT WAS MY FIRST NEW CAR. ABOUT A YEAR AND HALF AGO, WITHOUT A WARNING LIGHT -COMING ON TO ALERT ME OF AN IMPENDING PROBLEM, THE CAR BEGAN EMITTING HEAVY BLACK SMOKE FROM THE EXHAUST SYSTEM. THE CAR HAD GONE THROUGH AN OIL CHANGE JUST 200 MILES BEFORE. WHEN THE CAR WAS BROUGHT TO THE DEALERSHIP, THEY INFORMED ME THAT DUE TO MY WAITING TOO LONG TO CHANGE OIL, THE TURBO FAILED AND OIL MAY HAVE GOTTEN INTO THE ENGINE, MAKING IT NECESSARY FOR ME TO REPLACE THE ENGINE AND THE TURBO. THE DEALERSHIP REFUSED TO HONOR THE WARRANTY AND INSISTED THAT I SPEND A $3000-$6000 FOR THE REPAIR/REPLACEMENT AFTER SOME DISCUSSION, THE DEALERSHIP PROPOSED CLEANING THE ENGINE AND REPLACING THE TURBO AS AN ALTERNATIVE. AS THE PRICE WAS EXORBITANT, I TOOK THE CAR TO AN INDEPENDENT REPAIR SHOP WHICH PERFORMED THE TURBO REPLACEMENT AND ENGINE CLEAN-UP, CHANGING THE OIL AND COOLANT. THE CAR RAN FINE WITHOUT A PROBLEM UNTIL 11/26/05 WHEN THE E...

CRACK IN UPPER TANK OF SENDING UNIT RESULTING IN GAS LEAKAGE. 15 MONTH OLD DAUGHTER MAY HAVE BEEN AFFECTED BY THE TOXIC FUMES. *NM

IT HAS BEEN 4 TIMES ALREADY (SINCE AUGUST 2002) THAT MY CAR'S ENGINE HAS STALLED WHILE DRIVING. IN ALL INSTANCES THE ENGINE STARTS BACK UP AGAIN. I NOTICE RIGHT AWAY BECAUSE I LOOSE THE POWER STEERING. FIRST TIME [AUGUST 2, 2002]: THE FIRST DAY I BOUGHT THE CAR (BRAND NEW) I WAS AT A RED LIGHT AND THE CAR TURNED OFF. SECOND TIME: THIS WAS LIKE SEVERAL MONTHS AFTER. I WAS DRIVING ON THE HIGHWAY AND THE ENGINE TURNED OFF. THIRD TIME [JUNE 7, 2005]: I LEFT MY CAR AT THE DEALER FOR AN OIL CHANGE. THE DEALER TOOK MY CAR FOR A TEST DRIVE AND THE ENGINE STALLED ON HIM. I TOLD THEM THAT I HAS HAPPENED TO ME 2 TIMES PREVIOUSLY. THEY REPLACED THE STARTER SWITCH FOR THAT REASON. FOURTH TIME [JULY 16, 2005:] I WAS DRIVING UPHILL ON A ZONE WITH TIGHT CURVES AND THE CAR STALLED AGAIN. THIS TIME I ALMOST HAD AN ACCIDENT CAUSE THE TURNS WERE TIGHT AND I HAD NO POWER STEERING. *JB