-
Structure
10/27/2025
The passenger-side power sliding door system failed to stop or reverse when it encountered physical interference with the vehicle’s open fuel door. The door continued opening under power despite clear obstruction by a fixed exterior body component. The affected components, including the sliding door mechanism and damaged fuel door latch, remain available for inspection upon request. A powered sliding door continuing to operate against an obstruction creates a foreseeable risk of injury to occupants or bystanders, as well as vehicle damage. If a person’s hand, arm, or clothing had been in the same position as the fuel door, injury could have occurred. The incident occurred during normal vehicle use and demonstrates inadequate safeguards against obstruction. The issue has been formally reproduced or confirmed by an independent service center which noted that the incident occurred as described during normal operation of the power sliding door, and no abnormal conditions were present at t...
-
Electrical System
11/07/2025
Odometer Fraud. The contact purchased a 2014 Toyota Sienna. The contact stated that upon taking the vehicle to a dealer for an oil change, it was discovered through the Carfax report that there was a mileage discrepancy. The vehicle was a private sale through Facebook Market Place. At the time of purchase, the vehicle mileage was 146,000, but upon retrieving the Carfax report, the contact discovered that the mileage was 187,391 on the State inspection report dated June 18, 2025. The issue had not been reported to another agency.
-
Structure, engine
09/01/2025
The contact owns a 2014 Toyota Sienna. The contact stated that while driving 70 MPH, there was an audible alarm coming from the vehicle, alerting the contact that the door was ajar. The passenger’s side slide door opened independently while the vehicle was in motion. The vehicle was modified to accommodate a ramp for the contact's two wheel-bound children. The contact pulled over to the side of the road and closed the sliding door. The contact's husband tied the door to prevent it from opening independently again. The check engine warning light was intermittently illuminated. The vehicle was taken to the dealer, where it was inspected. The contact was informed that two latches had corroded and needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 16V858000 (STRUCTURE). However, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,500.
-
Latches/locks/linkages
06/13/2025
The passenger side cable that opens and closes the door snapped and is disconnected. The door will get stuck in an open or closed position.
-
Latches/locks/linkages
05/05/2025
The contact owns a 2014 Toyota Sienna. The contact stated that while opening the driver’s side sliding door, the drive belt snapped. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the sliding door drive belt. The vehicle was not repaired. The contact also stated that the same failure later occurred on the passenger’s side sliding door. The manufacturer was not notified of the failure. The failure mileage was 155,000.
