2008 Subaru Outback Complaints

When I braked downhill the main brake line, from front to rear, ruptured underneath in the middle of the Subaru. This car came from Wisconsin and apparently had a lot of rust, caused by salt, affecting the steel brake lines. Subaru calls Wisconsin the Salt Belt. I could avoid an accident, using the parking brake. I looked up recalls recently and learned that 2 recalls have been offered by Subaru. Only the first one was carried out: In 2014, after "6 years of rusting", they applied wax on the already rusted brake lines, to no avail. The second recall (there is a 40 pages document issued by Subaru) would require replacement of all 4 main brake lines, "in any cases of rupture". I contacted Subaru of Gwinnett (Georgia) and then SOA Subaru of America, case number 2210041700431 in order to get the second recall carried out, which was denied. I was told "Subaru has no further obligation, because the first recall was successfully (!) done" - in spite of the rupture! Now the vehicle, which h...

The contact owns a 2008 Subaru Outback. The contact stated while driving approximately 30 MPH, the passenger’s side air bag sensor light remained illuminated. The contact stated that the air bag warning light was also flashing. The failure became constant. The contact had not taken the vehicle to a local dealer. The vehicle was not repaired. The contact's husband had inspected the air bag sensor under the front passenger’s seat and determined that the sensor was functioning. The contact stated that her husband replaced the air bag sensor in the front passenger’s seat sun visor. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 128,000.

Brake pedal became less firm, and less effective, and Brake warning light came on. I was able to park my Outback, and saw evidence of brake fluid leaking from under the right rear passenger seat. After pulling the lower rear seat cushion off, and pulling the brake line grommet out of the body, I saw, through the hole the brake lines go through, a fitting that had bare rusty brake lines attached to it, covered in brake fluid, with plastic sheathing that started about an inch from the fitting. After I discovered that there have been a lot of outbacks with the same problem, I found out that there was a recall years ago, so I called a local dealership. The person I spoke with said that the previous owner of my vehicle had neglected to have the brake lines serviced during the recall and that the recall expired years ago, so I would have to pay for replacing the defective line myself.

Airbag dashboard warning light stayed on while driving on 1/31/2022 and 2/1/2022. Dealer (Autofair Subaru in Haverhill Massachusetts) confirmed there was a problem in the overhead console. Researching the problem, I came across https://www.subaruoutback.org/threads/2006-obw-airbag-light-on-my-fix.42574/ which identified a loose component on the printed circuit board caused by a crack in the solder. Cold weather seems to exacerbate the crack and cause the component to fail intermittently. Many have reported this problem with their Subaru and have made repairs by touching up the solder. Subaru states that the collision system may not function when this condition causes the Airbag Warning Light to remain on.

The contact owns a 2008 Subaru Outback. The contact stated while driving at 40 MPH and attempting to make a turn downhill, the brake pedal was depressed but failed to respond, causing the vehicle to crash into a ditch. There were no warning lights illuminated. The contact stated he did not sustain any injuries. The contact was unsure whether a police report was filed. The vehicle was towed to a tow lot, then it was towed to the contact's residence. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The contact stated he repaired the vehicle himself. The contact referenced NHTSA Campaign Number: 14V311000 (SERVICE BRAKES, HYDRAULIC). The dealer and the manufacturer were not made aware of the failure. The approximate failure mileage was 160,000.