-
Air Bags, seats
07/28/2026
Without an impact or collision, my car's passenger seat headrest shot out. I've been checking and others have done this as well. This morning, the driver's side headrest shot out without impact or collision. There is something wrong with the mechanism or airbags for the headrests. This can be extremely dangerous when in motion....
-
Service Brakes
12/29/2025
Dealer notes: Replace rear brake lines, found to be rusty recommend replacement with rear subframe replacement. This is a very well known issue and is not covered under recall from manufacturer. It will cost $3200 for brake line repair alone, not including the subframe. This is an extreme safety hazard and a common problem that has been acknowledged by the manufacturer.
-
Steering, service Brakes
09/18/2025
Subject: Safety Concern – Mercedes-Benz E350 4MATIC (2011) Subframe and Brake Line Rust Dear [Mercedes-Benz Customer Care / NHTSA], I am writing to report a serious safety concern regarding my 2011 Mercedes-Benz E350 4MATIC. Recently, I brought my vehicle in for recall service, and during the inspection, it was discovered that: The rear subframe is broken due to rust. The brake lines are extremely rusted, and I was advised that I could lose braking control if they are not replaced immediately. The estimated repair cost exceeds $4,000. I have been a long-time owner of Mercedes-Benz vehicles and part of the Mercedes-Benz family. However, I am now deeply concerned about the safety of myself, my family, and others on the road due to this severe corrosion issue, which I believe may be a widespread defect. I respectfully request that Mercedes-Benz investigate this issue and provide assistance, as the failure of these critical components poses a serious safety hazard. Thank you for you...
-
Suspension
09/22/2025
Rear crossmember or ( rear subframe frame ) rust and It broke due to corrosion
-
Service Brakes
08/28/2025
Brake lines have completely rusted through. Car had additional rust issues on the subframe which Mercedes admitted and replaced as part of an extended warranty . When that was repaired they never mentioned the brakes. Now 3 months later the brake lines rusted completely through … seems both subframe and lines rust at the same rate. And I would presume both cause equal safety risk. Why have they not yet issued an extended warranty on the brake lines? Both of these appear to be common issues. Hopefully NHTSA can encourage a change.
