2019 Mazda CX-9 Complaints

The engine cylinder head developed an internal coolant leak, allowing coolant to enter the combustion chamber. This caused engine overheating and smoke coming from the tailpipe while driving. A dealer performed a coolant pressure test confirming coolant leaking into the combustion chamber, and wet/dry compression testing on all 4 cylinders showed low and inconsistent readings consistent with cylinder head coolant intrusion (Cylinder 1: 105/125 psi, Cylinder 2: 115/125 psi, Cylinder 3: 110/175 psi, Cylinder 4: 160/190 psi). Overheating creates a risk of sudden loss of power and potential engine failure while driving, including on the highway. The problem has been confirmed and diagnosed by an authorized dealer service center, and the manufacturer's technical hotline department reviewed the diagnostic findings directly. Warning symptoms (overheating codes and visible tailpipe smoke) first appeared at the time the vehicle was brought in for diagnosis. The manufacturer has an active techni...

My 2019 Mazda CX-9 (VIN [XXX]) suffered catastrophic cylinder head failure on the SKYACTIV-G 2.5T engine at approximately 124,000 miles. The failure is consistent with Mazda TSB 01-013/21 (and successors 01-007/22, 01-010/24), in which Mazda acknowledged that cylinder heads on this engine can crack at the stud bolt hole and exhaust manifold flange due to manifold deformation and residual production stress. The first warning came in mid-May 2026, when the engine temperature warning illuminated during normal driving. An independent mechanic replaced the thermostat. The warning returned within a week, and the thermostat was replaced a second time with a higher-quality part. Four to five days later, the warning returned alongside more severe symptoms: the vehicle began jerking while in motion, a strong coolant-burning smell developed, and smoke was visible from the exhaust pipe upon shutdown. The vehicle became undriveable, had to be left at the failure location, and was towed. Safety risk...

- Coolant leak at cylinder head and turbo at only 63,000 miles. - Safety issue because no warning lamps or messages appeared and potential for car to overheat without coolant circulating in the system. Car could breakdown at worst time and location. Leaking coolant onto exhaust created potential for fire. - Problem has not been confirmed by dealer yet. Appointment is upcoming. - Symptoms of the problem were leaking coolant on ground, low coolant level, heater not working properly. - First appeared 1/29/2026.

Mazda has a current service alert ("SA", SA-001/23) for issues with their Gen 6 Infotainment Center Display, which covers issues (e.g. ghost touch, surface peeling, spider cracks, and white dots) and defects the occur on the primary display of the car. This display provides the driver with essential car operational information. This service alert applies to may of their vehicles in the 2014-2021 range, dependent on model. This VIN provided [XXX] ) is associated with a 2019 CX-9 that within the last month started displaying spider cracks at 2 of the 4 corners of the display. Even though this is a known (manufacturer) issue with other cars that utilize this display, the local Mazda dealership will not cover the replacement for this vehicle as the VIN range has not been included in this SA. The SA does not include CX-9s, but does include Mazda3 (Japan built) with applicable model years 2017-2018 (produced from June 27, 2016 to October 31, 2018). --> This 2019 CX-9 vehicle is Japan built...

The contact owns a 2019 Mazda CX-9. The contact stated that a State Inspection was performed on the windshield for cracks. The contact stated that while driving in the rain, the front windshield wipers turned on independently with the switch in the off position. The contact was unable to turn off the windshield wipers. The contact pulled over to the side of the road and turned off the vehicle. When the vehicle was restarted, the front windshield wipers had turned off. The contact stated that the failure persisted and worsened. The contact stated that occasionally the windshield wipers failed to turn off. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact purchased and replaced a sensor. Upon investigation, the contact became aware that the on and off switch for the front windshield wipers related to the sensor located on the front windshield. The contact stated that the sensor controlled the on and off switch and...