2020 Lincoln Navigator Complaints

Category: Power Train -> Automatic Transmission Subject: 2020 Lincoln Navigator – Repeated Missed Warranty Repairs – Transmission Neutral-Out & Violent Downshift at Highway Speed Description: On [XXX], while traveling at approximately 70 mph on [XXX], my 2020 Lincoln Navigator suddenly downshifted, free-wheeled into neutral, then violently re-engaged into a lower gear, chirping the rear tires and nearly causing a collision. The vehicle displayed a "Shift System Fault" warning. This defect matches TSB 23-2120 (momentary neutral-out) and TSB 24-2101 (harsh/delayed engagement) for the Ford/Lincoln 10R80 transmission used in the Navigator. TSB 23-2123 (harsh/delayed engagement/shift) also applies to my model year and transmission. I purchased this vehicle in December 2023 from Performance Lexus RiverCenter (Covington, KY) with the original Lincoln 6-year/70,000-mile powertrain warranty still in effect. According to Carfax, the vehicle was owned by Airport Ford, a Ford/Lincoln dealer, f...

Had transmission problems before this final issue. With that said the dealership ended up replacing the transmission as it was under warranty. Not even 2000 miles later we are coming back from vacation and I lost total power of the vehicle but since I was going around 70 mph we made it to the shoulder of the highway. Once there the vehicle was already smoking so we all got out of the vehicle and that’s when I saw the fire, and not even 3 minutes later it was totally in gulfed in flames.

The transmission system failed, causing jerking during acceleration. The original transmission was replaced by the dealer, so it may be available for inspection if retained by the dealer or returned to Ford/Lincoln. Jerking during acceleration can create safety risks including: unpredictable vehicle behavior during merging or passing, potential loss of control in traffic situations, and compromised ability to maintain consistent speed or smoothly accelerate away from hazards. Yes - the dealer confirmed the problem and determined the transmission required replacement, indicating they reproduced and verified the issue. Ted Britt Ford Lincoln, Chantilly, VA inspected the vehicle. No dashboard lights.

The contact owns a 2020 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 25V197000 (Seat Belts); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Was on Interstate when there was a loud bang, the transmission shifted harshly and I lost power where the vehicle would not go faster when i hit the pedal. I was basically pumping the gas for about 3-5 seconds before transmission re engaged. It was a dangerous situation in that I was at highways speeds about 65-70mph and i had no throttle control for several seconds. There was no warning when it happened and it re engaged and I was able to drive the vehicle home. Ford did replace the CDF drum under warranty but there should be a recall on this transmission. The the same thing happened in my other truck, an f150 which uses the same tranmission and engine combo.