2013 Lincoln Navigator Complaints

VEHICLE DOWNSHIFTED WHILE DRIVING. SPEEDOMETER STOPPED WORKING. STOPPED THE VEHICLE AND THE TRANSMISSION FAILED TO SHIFT OUT OF GEAR UPON ACCELERATION. CLUSTER SHOWED WRENCH AND ENGINE LIGHT. TURNED THE VEHICLE OFF THEN RESTARTED AND THE CLUSTER CLEARED AND OPERATION RETURNED TO NORMAL. A WEEK LATER, THE SAME INCIDENT. SEEMS TO BE THE PROBLEM THAT EXPIRED IN THE 2023 CUSTOMER SATISFACTION CAMPAIGN; HOWEVER, THE VEHICLE IS OUT OF THAT WINDOW.

While operating my 2013 Lincoln Navigator under normal driving conditions, a spark plug ejected from the cylinder head, causing immediate and catastrophic engine failure. The engine lost power and began producing severe mechanical noise, creating a potential safety hazard due to sudden loss of propulsion. Inspection by both an independent mechanic and an authorized Ford dealership confirmed that the spark plug ejection allowed debris to enter the combustion chamber, destroying internal engine components. The vehicle was properly maintained and this failure occurred without warning. This issue appears consistent with known problems involving the Ford 5.4L Triton engine design. Ford Motor Company has refused to escalate or investigate the failure despite documentation. Ford Motor Company Customer Relationship Center P.O. Box 6248 Dearborn, MI 48126 Re: Goodwill Assistance Request & Notice of Latent Defect Vehicle: 2013 Lincoln Navigator – 5.4L Triton V8 VIN: [XXX] Case Number: To Whom...

While driving at approximately 65-70 mph on a major interstate, the engine experienced a sudden catastrophic failure without warning. This caused an immediate loss of power and power steering/braking assist, making the vehicle extremely difficult to control in high speed traffic. This sudden stall endangered my life and the lives of nearby motorists. A certified mechanic inspected the engine internals (via borescope) and identified that a valve seat had dropped in the #4 cylinder, causing it to impact and destroy the piston. This 'dropped valve seat' failure is a known defect in Ford/Lincoln 5.4L engines. It occurred despite my meticulous maintenance history and constitutes a latent manufacturing defect that creates an unreasonable safety risk on public highways.

My truck on a few occasions suddenly down shift hard and on its own without warning, it could very much have cause an accident and could have been deadly at highway speeds, at the same time the speedometer would go to 0 and quit working, as well as multiple warning messages would pop up on message display. IE out of fuel, air system failure, orange wrench, Etc. Then after some time everything would go back to normal operation until it randomly did it again. This is a major safety issue for drivers and passengers as well as other vehicles around. At the dealer they gave me a print out from 2019 that states it was a safty recall 19S07 but the dealership said it was only a technical bullet not a safty recall and dealers not responsible for the cost but will reprogram the Powertrain Control Module (PCM) with updated calibration -Requires using IDS software release 113.06A or newer (internet connection needed) -No replacement parts needed—this is a software fix But in truth, this dose no...

As per Ford Customer Satisfaction Programs 19B05 and 19N01 down shift and molded lead frame. My truck was brought into the dealership to verify the problem. Codes revealed that the molded lead frame and output sped sensor went bad. My 2013 Navigator has 62,000 miles. It was determined that my vehicle was 60 something days over the time limit for the repair and I would have to pay the $1500 to cover the repair! Now I see Ford is issuing a recall! I had the vehicle at the dealer waiting for weeks to get the part. I took the vehicle back as the service advisor told me they did not know when the parts would arrive. I was driving the vehicle several days after picking it up and the rear wheels locked up doing 45 mph. The vehicle behind me hit the back right of my vehicle causing $1900 worth of damage!