-
Fuel System, Gasoline
07/15/2025
The contact owns a 2020 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (FUEL SYSTEM, GASOLINE). The contact stated that while driving 60 MPH, the vehicle was leaking fuel from the fuel tank. There was no warning light illuminated. The dealer was contacted and notified of the failure, and the vehicle was repaired. The contact stated that the failure was a recurring failure. The manufacturer was notified of the failure. The failure mileage was approximately 108,000.
-
Engine
04/01/2025
2020 Hyundai Sonata SEL Plus, VIN [XXX] . A/C system fails due to refrigerant leak that empties the system completely within 1-2 weeks of recharge. Leak cannot be located through standard external inspection. First noticed reduced cooling summer 2025. Driver's side loses cooling first, then passenger side fails days later — pattern consistent with evaporator core leak in dual-zone system. In September 2025, independent shop found system completely empty, recharged it, and attempted leak detection but could not locate source. Approximately two weeks later, system was empty again. Shop still unable to find leak. Symptom pattern — rapid total refrigerant loss, asymmetric failure (driver side before passenger), no externally detectable leak — points to evaporator core, which is enclosed in the HVAC housing behind the dashboard and invisible during standard inspection. Vehicle has 50,125 miles, still under the 60,000-mile warranty limit after 6+ years. Low-use vehicle averaging under 8,000...
-
Forward Collision Avoidance
05/29/2022
The contact owns a 2020 Hyundai Sonata. The contact stated while driving at various speeds, the vehicle experienced phantom braking and nearly came to a complete stop. The contact stated that the automatic emergency braking system unexpectedly engaged while there were no roadway obstacles or vehicles near the vehicle. The vehicle was taken to the dealer, who informed the contact that they would need to verify whether the repair would be covered under the active warranty. The vehicle was not yet diagnosed or repaired. The manufacturer was not yet contacted. The failure mileage was approximately 2,000.
-
Fuel System, Gasoline
04/11/2026
See attached document for complaint.
-
Fuel System, Gasoline, seats, engine
10/01/2024
The contact owns a 2020 Hyundai Sonata. The contact stated that the fuel failed to go into the tank. The seat failed to move. The engine light illuminated. The vehicle stalled. While driving, the fuel gauge went from full to empty. The contact received the NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline) after the failure. The vehicle was towed to the local where it was diagnosed that the fuel tank had expanded. The vehicle was repaired approximately eight months later. The contact called another local dealer. Ourisman Hyundai Bowie, 2404 Crain Hwy A, Bowie, MD 20716, who was unable to schedule an appointment. The manufacturer instructed the dealer to keep the vehicle due to it being a fire risk. The manufacturer was contacted regarding a buyback. The failure mileage was approximately 80,000.
