-
Steering, suspension
01/30/2015
I WAS DRIVING HOME FROM WORK ON JAN 30TH, 2015 AND THE CAR STARTED PULLING TO THE RIGHT. THE NEXT DAY, SAT THE 31ST, I JACKED UP THE RIGHT FRONT OF THE CAR TO SEE WHY THE CAR STEERED TO THE RIGHT. I FOUND THE LOWER WHEEL ASSEMBLY ATTACHMENT TO THE FRAME HAD COME LOOSE. THAT WAS BECAUSE THE FRAME HAD THREE OF FOUR SIDES RUSTED THRU. THE CONDITION COULD HAVE CAUSED A MORE SEVERE ACCIDENT IF THE ATTACHMENT TO THE FRAME HAD PULLED COMPLETELY APART. I WILL CHECK WITH HYUNDAI TO SEE WHAT THEY CAN DO ABOUT IT. THANKS FOR LISTENING. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
-
Steering, suspension, structure
03/19/2014
AFTER REMOVING THE DRIVERS FRONT WHEEL I NOTICED THE CONTROL ARM ATTACHMENT POINT SEVERELY RUSTED, & THE SUB FRAME CRACKED READY TO BREAK. I KNOW ABOUT THE RECALL. UNFORTUNATELY NEBRASKA ALONG WITH OTHER STATES WERE NOT INCLUDED. THIS CAR WAS WELL MAINTAINED BY THE ORIGINAL OWNER, & DRIVEN VERY LITTLE IN SALT/ SNOW CONDITIONS. SHE PURCHASED @ APPROX. 80 YEARS OF AGE. NHTSA SHOULD TAKE A LOOK AT THIS AGAIN. WATER BEING TRAPPED IN THE SUB FRAMES IS THE REAL PROBLEM, SALT MAY HAVE ONLY MADE THE FAILURE HAPPENED A BIT SOONER. I HAVE TALKED WITH HYUNDAI CUSTOMER ASSISTANCE, & WAS TOLD THE CAR WOULD NOT BE COVERED BY THE RECALL. I LIVE 8 MILES AWAY FROM IOWA, WHICH IS COVERED BY THE RECALL. OMAHA DOES USE SALT ON THE STREETS. 14 -15 YEARS FOR A SUB FRAME TO ROT AWAY SEEMS QUITE SHORT. THE PROBLEM IS A DESIGN DEFECT NOT ALLOWING THE WATER TO GET OUT. NO STATES SHOULD HAVE BEEN LEFT OUT! WHO DOESN'T WASH THEIR CAR REGULARLY? HOW MANY 1999-2004 MODELS OF THIS CAR ARE STILL ON T...
-
Air Bags
01/04/2014
L WAS STOPPED ON TRAFFIC ON HIGH WAY ,AND SOME ONE, HIT ME ON THE BACK ,THE GUY WAS SO FAST PROBLEM MORE THAN 75 MPH ,THAN MY CAR FLOAT 20 FOOT ,AND HIT THE CAR ON MY FRONT AND MY AIR BAGS DID NOT DEPLOY OR OPEN , SO THE QUESTION IS HYUNDAI SONATA 1999 USUALLY HAVE THIS PROBLEM , ???? *TR
-
Structure
11/01/2013
THE SUB FRAME/K FRAME ON MY 99 HYUNDAI SONATA RUSTED OUT CAUSING MY DRIVER SIDE REAR TIRE AND PASSENGER SIDE REAR TIRE TO FACE OUTWARDS ALMOST COMING OFF AND DAMAGING MY LEFT CONTROL ARM. I HEARD A LOUD POP AND COULDN'T FIGURE OUT WHAT IT WAS THEN REALIZED THE STEERING WHEEL WAS COCKED AT 180. I HAD TO DRIVE IT HOME WHICH WAS LUCKILY ONLY 2 MINUTES DOWN THE ROAD, I HAD TO DRIVE 10MPH SMELLING BURNING RUBBER. *TR
-
Suspension, structure
08/05/2013
I WAS PULLING IN A SHOPPING CENTER TURNING THE STEERING WHEEL TO THE RIGHT, I HEARD A LOUD BANG AND GOT OUT OF CAR, THE DRIVERS SIDE WHEEL WAS CAVED IN, HAD CAR TOWED TO MECHANIC, HE SAID THE SUBFRAME WAS COMPLETELY RUSTED AND BROKE AWAY FROM THE CAR, AND I WAS LUCKY THAT I WASN'T GOING AT A HIGHER SPEED. *TR
