2003 Hyundai Sonata Complaints

2003 HYUNDAI SONATA AFFECTED BY PROGRESSIVE, INTERNAL CORROSION OF THE RIGHT FRONT SUB-FRAME ON THE VEHICLE, AND RESULTING IN THINNING, RUSTING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION/RUST IS VISIBLE AND DISCOVERED DURING INSPECTION & ROUTINE MAINTENANCE, AND ALSO HEAR NOISES & NOTICE TIRE MISALIGNMENT AND STEERING PULL.THESE SIGNALS ARE DETECTING THE CORROSION PROGRESSING AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM DETACHING FROM THE SUB-FRAME. THE VEHICLE WAS BOUGHT NEW IN NEBRASKA, AND HAS REMAINED IN NEBRASKA ITS ENTIRE LIFE. NEBRASKA USES SALT ON ITS ROADS IN THE SAME CAPACITY AS IOWA AND OTHER "SALT STATES". SUCH CARS SHOULD BE INCLUDED IN THE RECALL WHEN CONSIDERING THE LACK OF SAFETY AND DANGERS INVOLVED WHEN THE SUBFRAME DETERIATES DUE TO DEFECTS IN THE MANUFACTURE OF SAID CAR. HYUNDAI SHOULD HONOR AND EXTEND THE RECALL OF SAID CAR IN THE STATE OF NEBRASKA BECAUSE THE DEFECT IN THE SUBFRAME HAS BEEN AFFECTED IDENTICALLY AS IN OTHER "SALT STATES".

TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED AND THE VEHICLE WAS LEAKING BRAKE FLUID. THE CONTACT ALSO STATED THAT THE AIR CONDITIONER FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR CONDITIONER COMPRESSOR FAILED AND THE BRAKE SENSORS WERE REPLACED; HOWEVER, THE AIR CONDITIONING SYSTEM WAS NOT REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 144,967.

REPORT RECEIPT DATE: MAY 21, 2009 NHTSA CAMPAIGN NUMBER: 09V171000 COMPONENT(S): LATCHES/LOCKS/LINKAGES SIMILAR ISSUE IS HAPPENING IN MY 2003 HYUNDAI SONATA VEHICLE. A CHILD IN MY BACK SEAT JUST SLICED THEIR HAND WITH A 2" INCH CUT AND WE HAD 3 OTHERS SLICE THEIR HAND ON THE FRONT DOOR HANDLE (WE TAPED THIS) BUT WAS NOT AWARE OF BACK SEAT NOR RECALL TILL TODAY. VERY CONCERNED AS TO SAFETY OF CHILDREN IN BACK SEAT. I ONLY REALIZED THIS HAPPENED TO ALL DOOR HANDLES AND THEIR HAD EVEN BEEN A RECALL AS THE PARENT OF THE INJURED CHILD SAID THEIR CAR HAD BEEN RECALLED FOR THIS ISSUE. I CALLED HYUNDAI 4/13/2016 TO DISCUSS AND WAS TOLD MY VIN NUMBER WAS NOT PART OF THE RECALL ALTHOUGH THE EXACT SAME ISSUE. ALL CHROME IS PEELING FROM TOP OF HANDLE AT THE SEAM ON ALL 4 INTERIOR DOOR HANDLES.

REPEATED USE OF THE INTERIOR DOOR HANDLE MAY CAUSE WEAR OF THE CHROME PLATE. IF THE TOP EDGE OF THE HANDLE HAS VERY THIN CHROME PLATING, THAT PORTION OF THE PLATING MAY WEAR AWAY MORE EASILY THAN MORE THICKLY PLATED AREAS AS THE DOOR HANDLE IS USED. THE WORN CHROME PLATING ON THE UPPER EDGE OF THE HANDLE MAY RESULT IN A CRACK OR SEPARATION BETWEEN THE CHROME PLATING ON THE INBOARD AND OUTBOARD SURFACES OF THE HANDLE, WHICH MAY FORM A SHARP EDGE. CONSEQUENCE: THIS MAY INFLICT LACERATION INJURIES TO ANYONE USING THE DOOR HANDLE. BASICALLY WHEN YOU GO TO USE THE INSIDE DOOR HANDLES THE PEELING CHROME IS SHARP AND CUTS YOUR FINGERS. HYUNDAI RECALL #93 ENDED IN MARCH 2003, MY CAR WAS MANUFACTURED IN MAY 2003. THE PROBLEM IS IDENTICAL TO THE MODELS IN RECALL #93.

MY VEHICLE IS AFFECTED BY THE FOLLOWING SAFETY RECALL IN WHICH THE INTERIOR DOOR HANDLES ARE PEELING AND THE TOP EDGE BECOMES SHARP - I TAPED OVER THE TOP SO I WOULDN'T CUT MY HANDS IN THE MEANTIME: NHTSA CAMPAIGN ID NUMBER : 09V171000 / HYUNDAI RECALL NO. 093. I BROUGHT IT FOR SERVICE AT MOTORWORLD HYUNDAI IN WILKES BARRE, PA AND THEY VERIFIED ALL DOOR HANDLES WERE PEELING. THE INITIAL RECALL REPAIR FOR THIS CAMPAIGN WAS PERFORMED ON 11/11/2009, BUT CLEARLY THE REPAIR DID NOT REMEDY THE PROBLEM AS IT RECURRED. MOTORWORLD TOLD ME THEY HAD TO CONTACT HYUNDAI CORPORATE FOR AUTHORIZATION FOR THE REPAIR. I WAS CALLED BACK AND TOLD THEY WOULD ONLY PAY FOR PARTS BUT NOT LABOR. THIS SURPRISED ME, AS A SAFETY RECALL IS SUPPOSED TO BE REMEDIED AT NO COST TO THE CONSUMER. I THEN CONTACTED HYUNDAI CUSTOMER SERVICE 4 TIMES, ON 1/20, 1/27, 2/10, AND 2/18 OF 2016 AND EACH TIME I WAS TOLD I WOULD RECEIVE A CALL BACK, WHICH I NEVER RECEIVED. I THEN CONTACTED AN ATTORNEY FOR ADVICE AND THEY TOLD M...