-
Air Bags
02/24/2018
TL* THE CONTACT OWNS A 2001 HYUNDAI SONATA. WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, THE DRIVER'S SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
-
Suspension, structure
09/04/2017
TL* THE CONTACT OWNS A 2001 HYUNDAI SONATA. WHILE MAKING A RIGHT TURN, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT PASSENGER SIDE TIRE. IT WAS DISCOVERED THAT THE CONTROL ARM HAD FRACTURED FROM THE FRAME, WHICH WAS CRUMBLING DUE TO RUST AND CORROSION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THEN TOWED TO THE CONTACT'S RESIDENCE AND TO THE DEALER (HYUNDAI OF CHANTILLY, 14848 STONECROFT CENTER CT, CHANTILLY, VA 20151, (703) 480-9000). THE CONTACT WAS NOT SURE IF THE VEHICLE WAS INCLUDED OR EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION). THE MANUFACTURER WAS TO PROVIDE A FOLLOW-UP RESPONSE TO DETERMINE THEIR SOLUTION FOR THE DEALER'S REPAIR. THE VEHICLE WAS UNABLE TO BE DRIVEN DUE TO THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.
-
Air Bags, seats
02/07/2017
PASSENGER SENSOR RIGHT FRONT,SENSOR FOUND IT FAULTY,THIS SENSOR IS UNDER THE FABRIC OF SEAT.LIGHT IS ALL WAYS ON.
-
Fuel/propulsion System
07/29/2016
BAD FUEL VAPOR SMELL IN CABIN, NO CHECK ENG LIGHT ON. CHECKED ENG LIGHT AT AUTO ZONE ANYWAY, CODE SAID VAPOR VALVE GOING TO CANISTER/DUMP AFTER WARM UP. HYUNDAI BY PHONE SAID CANISTER NEEDED REPLACED($400+). I LIVE ON DISABILITY SSI, TOO EXPENSIVE. TOOK TO SMALL GARAGE, AFTER LIFTING, BOTTOM OF GAS TANK WAS WET WITH GAS(BY THE EXHAUST). ONE GUY WENT TO ACCESS POINT FOR FUEL TANK FOR REPLACING FUEL PUMP. A 6 INCH RUBBER HOSE CONNECTING THE LINE OUT OF THE FUEL TANK CONNECTING TO METAL RAIL FUEL LINE BENT AT OVER 90 DEGREES, HAD A HOLE AT THE WEAKEST POINT, IN THE INSIDE BEND. I AM NOT THE FIRST OWNER, BUT [XXX], COULD ONLY DRIVE IT AFTER MIDNIGHT IN HOT SUMMER. CODE EXPLAINED CAR AFTER WARM UP OPENS THIS VALVE TO DUMP VAPOR BUILD UP IN CANISTER. SOUNDS RIGHT, CODE AND EVERYTHING, AFTER I FINALLY HAD THEM CHECK FOR CODES WITHOUT CHECK ENGINE LIGHT NOT COMING ON. SUCH A CHEAP COST OF A RUBBER HOSE COULD HAVE EASILY BEEN A BRADED FLEXIBLE METAL CONNECTION. [XXX], I'M LUCKY. I GAVE HYUNDAI...
-
Steering, structure, unknown Or Other
08/15/2016
WAS INFORMED APPROXIMATELY 2006-2007 BY GOOD SAMARITAN, BILL OSTERHAGE, THAT HIS DAUGHTER'S 2002 HYUNDAI FRONT TIRE ROD AXIAL BROKE D/T MAJOR CORROSIVE ISSUES WITH FRAME DEFECTS. HE CONTACTED AN ATTORNEY FOR CLASS ACTION LAW SUIT TO BE STARTED D/T SAFETY ISSUES TO PREVENT DEATH TO OTHERS & REPAIR FRAME TO ROB CAREY AT ROB.CAREY @ATT.NET & AMYW@HBSSLAW.COM. FROM 2006- UNTIL 2009 DURING ROUTINE OIL CHANGES, I ASKED KERRY HYUNDAI IN ALEXANDRIA, KY TO CHECK MY FRAME D/T VISUAL RUST & ABOUT RECALL. HYUNDAI FINALLY ADMITTED AFTER MULTIPLE COMPLAINTS DURING ROUTINE MAINTENANCE IN A LETTER TO ME ON 6/24/09 THAT THERE WAS A RECALL ON 4/16/09 AND MY FRAME TO BE REPLACED. 8/15/16 I LOST CONTROL OF MY 2001 SONATA, HYUNDAI WHILE DRIVING ON EXPRESSWAY DURING RUSH HOUR D/T MAJOR CORROSIVE ISSUES CAUSING RIGHT REAR TIRE ROD TO BREAK. I DID TWO 360 DEGREE TURNS FROM FAST LANE TO SLOW LANE. GRACE OF GOD I DIDN'T CRASH OR CAUSE ANY ACCIDENTS. FILLED REPORT WITH HYUNDAI DEALER & CORPORATION 8/16/16....
