-
Air Bags, seat Belts
03/26/2024
Airbags: passenger rear and front side airbags did not deploy after being struck on the passenger side by another vehicle. Seatbelts: were ineffective Vehicle was sold due to system failures and equipment issues. Safety: Head and body trauma due to non deployment. Inspection: Unknown No system messages before collision
-
Power Train
02/27/2026
10th gear, gear ratio incorrect. CDF drum failure. Rough shifts from 3-4 struggles to shifts into park and reverse.
-
Suspension
03/09/2026
Vehicle has around 50K miles and driver rear leaf spring corroded and broke, review of right rear leaf spring also showed corrosion and metal thinning. Truck has no off road time nor heavy loads in bed. I had to replce both springs at my cost even though Ford is aware of the 2019-2020 Ranger spring issues and refused to replace the springs. This is a serious safety issue that places the occupants and other drivers at risk. The mechanic said he’s replaced over a dozen broken leaf springs on model years 2019 and 2020. The manufacturer is being intentionally negligent and even the dealer parts counter agreed the springs are faulty, saying they sell quite a few regularly.
-
Power Train, engine
02/02/2026
My truck experienced a P0302 misfire on the freeway, which caused it to shake immediately and made it very difficult to drive. I had it towed to the dealership, and they told me there was water in the spark‑plug wells, which was surprising since I live in Las Vegas, NV, where it rarely rains. My spark plugs were rusted as well as the cylinder head. After looking into it online, I discovered that Ford issued TSB‑23‑2011 for the Ford Ranger due to a windshield cowl leak that allows water to drip directly onto the engine. Their proposed fix is to install an engine cover, but that clearly doesn’t solve the issue since my truck already has the engine cover installed. Now I’m stuck paying for repairs caused by a design flaw that Ford never properly addressed.
-
Unknown Or Other
02/20/2026
he 2019 Ford Ranger the VIN [XXX] , the driver’s side AC only blows hot due to the climate control issue addressed in Fords service bulletin SSM 51313. This is a known issue with the early production model of the Ranger, hence the service bulletin SSM 51313. It is my belief that faulty parts were used on the early model Rangers and instead of a recall or extending the warranty on this issue only issued a service bulletin was put out. I am writing to have the Ford MOCO issue the proper recall or cover repairs under and extended warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
