-
Suspension, engine, fuel/propulsion System
06/02/2005
VEHICLE BODY AND STRUCTURAL FRAME HAVE ABNORMAL CORROSION AND RUST AND CRITICAL COMPONENTS HAVE FAILED. CAB IS ATTACHED TO FRAME WITH FOUR BOLTS. THE METAL AROUND THE FRONT LEFT BOLT HAD COMPLETELY RUSTED AWAY. CAB IS THEREFORE ONLY HELD DOWN NOW BY THREE BOLTS. RIGHT FRONT COIL SPRING TOWER ROTTED AND WAS SUBJECT TO COMPLETE FAILURE WHICH WOULD CAUSE THE RIGHT FRONT OF THE VEHICLE TO FALL DOWN ONTO THE SHOCK ABSORBER. TIRE WOULD HAVE BEEN THRUST INTO FENDER WELL AND STEERING WOULD BEEN COMPRIMISED. REPAIRED IN 2006. GAS TANK MOUNTING STRAPS RUSTED AWAY SUBJECTING THE TANK TO FALL FROM VEHICLE. REPAIRED IN 2005. LEFT REAR LEAF SPRING ATTACH BRACKET (SHACKLE) RUSTED AND BROKE, CAUSING VEHICLE TO FALL ONTO END OF LEAF SPRING, WHICH IS NO LONGER ATTACHED. ENGINE OIL PICK UP SCREEN BECAME CLOGGED WITH DETERIORATED OIL PAN GASKET MATERIAL. ENGINE BECAME STARVED OF OIL AND SEIZED UP WHILE DRIVING IN HEAVY TRAFFIC, CAUSING A MAJOR HAZARD. ENGINE WAS REPLACED IN 2016.
-
Electrical System, engine
04/20/2016
TL* THE CONTACT OWNS A 1989 FORD RANGER. WHILE DRIVING AT LOW SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT, A CERTIFIED INDEPENDENT MECHANIC, DIAGNOSED THE VEHICLE AS HAVING SECONDARY IGNITION FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 64,000.
-
Tires
01/15/2015
TL* THE CONTACT OWNS A 1989 FORD RANGER EQUIPPED WITH HERCULES H/P 4000 TIRES, SIZE: 215/70R14 (NA). THE CONTACT STATED THAT THE FRONT DRIVER SIDE TIRE WAS CRACKING AND EXPERIENCED TREAD SEPARATION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS RECOMMENDED TO REPLACE ALL THE TIRES. THE TIRES WERE REPLACED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 150 AND THE VEHICLE FAILURE MILEAGE WAS 50,400.
-
Tires
03/17/2009
TL*THE CONTACT OWNS A 1989 FORD RANGER. THE VEHICLE HAS FIRESTONE FR380 TIRES, SIZE P215/70/R14. THE CONTACT NOTICED THAT THE TIRES WERE ALMOST FLAT. UPON FURTHER INVESTIGATION, HE NOTICED THAT THE TREAD LINES WERE BECOMING LOOSE AND APPEARED TO BE PEELING OFF. THE FAILURE MILEAGE ON THE TIRES WAS 12,781. THE FAILURE MILEAGE ON THE VEHICLE WAS 118,000.
-
Fuel System, Gasoline
01/22/2009
1989 FORD RANGER. FAILED SMOG TEST FOR THE FIRST TIME. TOLD NEW TEST FOR SEAL IN GAS FILLER DOWN TUBE RESULTS IN PRETTY MUCH ALL VEHICLES OF THIS TYPE FAILING CALIFORNIA SMOG TEST. SUGGESTED FILE COMPLAINT AS THIS SHOULD BE A RECALL FROM MANUFACTURER (FORD) TO CORRECT THIS DEFECT. *TR
