-
Electrical System
03/18/2025
The contact owns a 2004 Ford F-350. The contact stated that while driving approximately 76 MPH with his wife in the front passenger seat, the vehicle shuddered uncontrollably and stalled. The contact and his wife were concerned for their safety. There was no warning light illuminated. The contact was able to regain control of the vehicle and pulled over to the side of the road. The vehicle failed to restart and was towed to the residence. The contact stated that as an independent mechanic, he used a code reader to retrieve diagnostic trouble codes for the fuel control module wiring harness failure. The contact related to the failure to NHTSA Campaign Number: 05V270000 (Electrical System). The contact stated that the fuel control module wiring harness failure had caused warning lights to fail to illuminate as needed. The dealer was notified of the failure and informed the contact that the vehicle had previously been repaired under the recall. The manufacturer was notified of the failure...
-
Engine, unknown Or Other
04/14/2022
While driving at 40-50 MPH the vehicle will lose power and then then stalls while moving leading to loss of power. The loss power of affects the power steering posing a direct threat for an auto collision due to the difficult in steering the moving vehicle into an emergency lane. Avoided several accidents with this truck. Once it is stalled it can take numerous times to restart the vehicle. This issue seems to occur more on slopes going up hill. This does not seem to occur as often going downhill or on areas with no incline. Currently vehicle has 126,931.8 miles on it. Regularly serviced and otherwise running fine.
-
Tires
09/24/2021
The contact owns a 2004 Ford F-350 equipped with Cooper Tires, Tire Line: Discover AT3, Tire size: 265/75/R16, DOT Number: UPWM1M11718M16L. The contact stated that while driving 65 MPH, the rear driver’s side tire had a sidewall blowout. The contact stated that all four tires had sidewall blowouts months apart. The tire blowouts had damaged the rims. The contact replaced the front driver’s, passenger’s, and rear driver’s side tire with the spare after each blowout. The dealer was made aware of the failure and replaced the rear passenger’s side tire. The manufacturer was made aware of the failure and the rear driver’s side rim, rear driver’s and front passenger’s side tire were sent to the manufacturer. The failure mileage was not available.
-
Engine, fuel/propulsion System
09/18/2020
MY TRUCK HAS MAJOR ENGINE DAMAGE BOUGHT IT AND THREE DAYS LATER THE EGR WENT OUT THEN NEXT THING YOU KNOW I GOT A BLOWN MOTOR
-
Fuel System, Gasoline
09/13/2020
TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE HOWEVER, THE FAILURE RECURRED. UPON INSPECTION, THE CONTACT DISCOVERED THE FUEL FILTER WAS COVERED WITH SILVER DEBRIS. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER WAS CONTACTED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 332,000.
