2003 Ford Expedition Complaints

The contact owns a 2003 Ford Expedition. The contact stated while driving 45 MPH, the engine was misfiring, and the contact smelled a burning odor inside the vehicle. The check engine warning light was illuminated. The contact was able to drive to his residence. The contact stated that the failure had been reoccurring while driving. The vehicle was taken to an independent mechanic on five occasions where it was diagnosed that water was leaking into the ignition coil. The independent mechanic installed silicon around the boot to prevent water from leaking into the coils; however, the failure persisted. The dealer was notified of the failure and informed the contact it was not a known failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 196,000.

bought truck 3/2/22 from Gold cAuto In troy NY. 3/7/22 went to take kids to school 2.5 inches of water set in my weather guard mats. seats soaked console everything in front cab reversed to pull out spot and water starting pouring on my and my kids from sides in pass sides front and the front windshield area omgand the sun roof was worst.kids had to go in myslef too it was snow still out.so that dayi oh sunroof needs to be blown out i said well that right frontdoor sounds open when its shut . same night i picked it up said all was good to go and his guy didn't hear any issues with door. the next snow it was worst this was about toward end of march. i called back around 3/15 said its still leaking dude i just want my money back for real and we are good, he said no doesnt work liek that said all his winshield guy he would take a lok at it and tell hijm ihe sent me. did that talked to the guy said he woudl call me the next day week went by so i called him back long story short he sai...

This vehicle has a faulty engine. The aluminum that Ford used to create the top end is too thin to support the pressure of the engine. As a result spark plugs explode from the engine at random with no warning. This has happened 5 times even after replacing all spark plugs, numerous coils and having kits installed by a mechanic sold by Ford to address the issue. $475 per kit from Ford. This is an enormous safety issue. The last one that blew out was on the highway with my two toddlers in the car.

THIS IS THE 2ND TIME IT HAPPENED TO MY 2003 FORD EXPEDITION. WHILE DRIVING HEARD A LOUD POPPING NOISE, FOLLOWED BY CONTINUOUS POPPING LOUD POPPING NOISE LIKE A BROKEN EXHAUST MUFFLER, SOUNDED LIKE A MOTORCYCLE. AFTER INVESTIGATING, FOUND OUT THAT THE #3 SPARK PLUG POPPED OUT (EJECTED) OF THE HEAD CYLINDER, BROKE THE SPARK IGNITION COIL. WHEN THIS HAPPENED, I SMELLED FUEL, AND SAW SMOKE COMING FROM UNDER THE HOOD, SO I DID NOT DRIVE THE CAR AND TOWED THE CAR HOME. I HAD TO REPLACE THE IGNITION COIL AND SPARK PLUG AND REINSTALLED THE SPARK PLUG BUT IT SEEMED TO BE STILL LOOSE, SO I TOOK IT OUT AND PUT THREAD LOCK AND REINSTALLED IT BUT DID NOT TIGHTEN IT TO THE MAX AND DID NOT START THE CAR TILL AFTER 24 HOURS SO THE THREAD LOCK WILL HOLD IT IN PLACE. YESTERDAY THE SAME THING HAPPENED TO #8 SPARK PLUG, IT ALSO BROKE THE COIL, AND WHEN I TRIED TO INSTALL THE NEW SPARK PLUG, FOUND OUT THAT THE THREADS ON THE HEAD CYLINDER WILL NOT GRAB THE SPARK PLUG, AND NOW I AM STUCK WITHOUT A CAR. WHEN...

Faulty fuse panel. This is a known issue. It is ALL over the internet. There has never been a recall. The vehicle will stall while driving. On attempting restart or crank, there is a buzzing noise from the fuse panel. The pcm #203 I believe, corrodes or melts through the board on the panel causing the fault. Replacing the fuse/relay will correct, but for a time. Panel replacement is required. First incident at 165k. Second incident at about 205k. After the last panel replacement, the vehicle continued to stall. Another faulty fuse, for the day running lamps, caused a fault, which melted the housing between the panel and the wiring harness. The screw attachment is "crunchy" because of the melted elements. The smell is noticeable, and the panel requires replacement again. Third incident about 246k. This is a fire hazard. The wiring harness is hot to the touch. Being a KNOWN issue, having discussed on various socials and with ford dealer techs, this should have been recalled ages ag...