-
Engine And Engine Cooling
05/10/2006
ENGINE STALLS INTERMITTENTLY, WITH OR WITHOUT A/C. CAN HAPPEN AT ANY TIME AFTER START UP AND AT ANY SPEED WITHOUT WARNING. SOMETIMES CAN HAPPEN AFTER VEHICLE GOES OVER A BUMP (EVEN SMALL ONES), DURING TURNS, MOVING OFF FROM A TRAFFIC LIGHT. THIS IS HIGHLY DANGEROUS. DEALER DID INSTALL KIT TO PREVENT POTENTIAL STALLING DUE TO OPERATION OF HEAVY DUTY REAR A/C DURING TURNS (KNOWN PROBLEM) BUT NO EFFECT. ENGINE RESTARTS WITHOUT HESITATION AFTER IGNITION KEY IS SWITCHED OFF AND THEN TURNED ON. DEALER HAS CARRIED OUT AN EXTENSIVE ELECTRICAL CHECK WITH NO RESULTS AND CANNOT DUPLICATE EVENT. *TR
-
Engine And Engine Cooling
11/21/2006
TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. WHILE DRIVING 65 MPH, THE VEHICLE SPEED DECREASED DRAMATICALLY. THE ENGINE WARNING LIGHT ILLUMINATED AFTER THE VEHICLE DECREASED IN SPEED. HE TOOK THE VEHICLE TO THE DEALER ON NINE OCCASIONS AND THEY REPLACED THE ERG VALVE, TURBO MANIFOLD, AND THE TURBO RESONATOR. THE CONTACT STATED THAT IMMEDIATELY AFTER THE REPAIRS WERE MADE HE EXPERIENCED A SIMILAR FAILURE. THE FAILURE MILEAGE AS 51,000 AND CURRENT MILEAGE WAS 78,000.
-
Steering
06/08/2007
RACK AND PINION WAS REPLACED AFTER LEAKAGE OCCURED AT 27000 MILES. IT IS LEAKING AGAIN BUT NOT COVERED UNDER DRIVE TRAIN WARRENTY AND DODGE REFUSES TO REPLACE IT. HOWEVER IF THIS IS A REOCCURING PROBLEM YOU SHOULD INSIST THAT DODGE MODIFY THE DESIGN AND EFFECT A RECALL.
-
Engine And Engine Cooling
01/30/2007
FAN PULLEY DISLODGES AND TEARS UP THE FRONT ACCESSORIES. DURING EXTENSIVE TRAVELS I HAVE FOUND DOZENS OF SPRINTERS HAVING HAD THE SAME PROBLEM. I THINK THAT THE DESIGN OR MATERIALS THAT MAKE UP THE PULLEY ARE FLAWED AND YOU SHOULD INVESTIGATE. I FURTHER BELIEVE THE DESCREPENCY BASED ON CONVERSATIONS WITH MECHANICS IS WELL KNOW TO DODGE YET IS ALSO COVERED UP BY DODGE.
-
Tires
08/27/2006
WHILE PARKED IN MY DRIVEWAY TIRES INFLATED TO 60 PSI MAXIMUM 65 PSI, LEFT FRONT TIRE SUDDENLY DEFLATED. THE VALVE STEM CORE SEPARATED FROM THE RUBBER CAUSING THE TIRE TO DEFLATE. THE VALVE STEM WAS REPLACED.THIS IS ON A 04 3500 DODGE SPRINTER AND IS NOT COVERED UNDER THE VALVE STEM RECALL ACCORDING TO DODGE.*AK
