2002 Bmw M5 Complaints

THERE ARE NO POWER MODIFICATIONS TO MY VEHICLE, I JUST RECENTLY INSTALLED A LOWER MILEAGE ENGINE, ALONG WITH ALL OF THE PARTS SURROUNDING THE ENGINE AND TRANSMISSION (IE CLUTCH, FLYWHEEL, THROWOUT BEARING, CLUTCH FORK, ETC). THE BREAK-IN PERIOD FOR A NEW CLUTCH IS 500 MILES OF NORMAL DRIVING AND 1000 MILES FOR THE ENGINE. I COMPLETED THE BREAK-IN PERIOD ON SATURDAY JULY 20, 2019, FOR THE CLUTCH BUT STILL HAVE SOME MILES TO GO FOR THE ENGINE BREAK-IN, SO ON 7-24-19 I WAS ENTERING THE FWY FROM A STOP LIGHT AND WHEN I PUSHED THE GAS PEADAL IT SOUNDED LIKE SOMETHING EXPLODED AND I HADN'T EVEN GOTTEN OUT OF 1ST GEAR YET!!! SO, I PULLED OVER TO THE SIDE OF THE ROAD, B/C I HEARD SOMETHING RUBBING, AND CALLED A TOW TRUCK TO TOW IT BACK TO THE SHOP THAT HAD JUST INSTALLED THE NEW ENGINE. THE SHOP CONTACTED ME WITH NEWS AND PICTURES, SHOWING ME THAT THE FACTORY WELDS ON THE DIFFERENTIAL'S SUBFRAME MOUNT HAD SNAPPED APART, DROPPING THE DIFFERENTIAL FROM ITS CORRECT POSITION AND DESTROYING MY DRI...

I HAVE A 2002 525I WHICH I DROVE TO WORK ON JANUARY 15, 2019. AFTER BEING IN WORK FOR 15 MINUTES, I WAS NOTIFIED THAT THE ENTIRE FRONT END OF MY CAR WAS ENGULFED IN FLAMES. THE TOP OF THE HOOD, UNDER THE HOOD, AND UNDER THE FRONT END OF MY CAR WAS COMPLETELY ON FIRE. I HAVE READ ABOUT THE PVC RECALL FOR 2007-2011, BUT I ALSO READ "BMW HAD LOOKED INTO HEAT DAMAGE INVOLVING THE HEATING AND COOLING SYSTEM AS EARLY AS 2007 BUT STEPPED UP ITS ANALYSIS WORK IN SEPTEMBER." THAT WAS FROM A CHRONOLOGY REPORT PROVIDED BY BMW TO NHTSA, AND QUOTED FROM ABCNEWS.GO.COM. WHAT THIS TELLS ME IS BMW DIDN'T LOOK BACK ANY EARLIER THAN 2007. IT WAS TERRIFYING, AND THANK GOD NO ONE WAS HURT. WHAT IS BMW DOING ABOUT THIS? AND WHAT IS MY NEXT COURSE OF ACTION?

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW M5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V047000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

WHILE MOVING THE SEAT FORWARD (VALET MOVED IT BACK) WE FOUND THAT THE SEATS TWISTED; IN OUR CASE, THE OUTER SIDE OF THE SEAT BOTTOM MOVED FURTHER THAN THE INNER SIDE, CAUSING THE SEATS TO TWIST TOWARDS THE CENTER OF THE CAR AND LEAVING THEM UNEVEN WITH THE DASH AND FRONT OF THE CAR. ATTEMPTS TO CORRECT THE SEAT POSITIONING BY MOVING THE SEAT BACKWARDS VIA POWER SWITCH CAUSED THE INNER BOTTOM PORTION OF THE SEAT (AROUND THE THIGH BOLSTERS) TO BIND AND JAM AGAINST THE CENTER CONSOLE. WE FOUND THAT THE POWER PASSENGER SEAT HAD THE SAME PROBLEM. WE RESEARCHED THE ISSUE ON BMW-RELATED WEBSITES (IN PARTICULAR, M5BOARD.COM) AND FOUND THAT EACH SEAT HAS THREE SEPARATE MOTORS THAT ARE SUPPOSED TO MOVE IN UNISON WITH THE CONTROL SWITCH VIA ONE CABLE. AS DESIGNED AND BUILT, THESE POWER CABLES LEADING TO EACH MOTOR ARE TWISTED TO FIT WITHIN THE CONFINES OF THE UNDER SEAT DESIGN. THE CABLE END ADJACENT TO EACH MOTOR MAKES CONTACT DURING NORMAL SEAT MOVEMENT WITH OTHER UNDER-SEAT COMPONENTS. AF...

DRIVING AT 50 MPH I WAS BEING HARASSED BY ANOTHER MOTORIST BECAUSE I WAS DRIVING THE SPEED LIMIT. I DECIDED TO LET HIM PASS BUT FIRST I HAD TO SPEED UP TO 58 MPH INORDER TO COMPLETELY OVERTAKE A PASSENGER CAR TO MY RIGHT (PASSENGER SIDE) I GAVE THE THROTTLE SOME GAS AND THE CAR WENT NOWHERE. THE NEEDLE WENT ALL THE WAY INTO THE RED ZONE ON THE TACHOMETER. THE DRIVER BEHIND ME (ANOTHER BMW 3 SERIES),TAILGATED ME. IT SCARED ME SO BAD, THAT I DID NOT SEE A DEEP POT HOLE IN THE ROAD SURFACE. I HIT IT SO HARD, THAT I SPUN AROUND AND ALL OF MY WHEELS WERE DAMAGED. I HAD ALL FOUR WHEELS REPAIRED AND TIRES AT A COST OF $2000.THE DAY BEFORE, I NOTICED THE SERVICE ENGINE SOON LIGHT WAS ON. OF COURSE, I WANT THIS CHECKED OUT.SO I SCANNED THE CAR. IT WAS DISPLAYING 000030 BMW/ OR FOR/ P CODE P0741 " TORQUE CONVERTER CLUTCH VALVE STUCK OFF .SO I WENT TO A BMW DEALER. EXPLAINED EVERYTHING. THEY SHOW ME THE CODES PULLED FROM THE CAR. THE CODE FOR THE TC CLUTCH VALVE NOT WORKING WAS SHOWN.(THEIR EQUI...