2021 Acura TLX Complaints

I took this vehicle to get serviced in the summer of 2025. I recently joined an Acura Type S (2021+) group on Facebook and learned that the issue is quite prevalent. I had to have the transmission and transfer case replaced due to transmission issues and traction issues

On July 7th 2026 I was driving home, came to a stop light at normal speed, when the light turned green I took off at normal speed and I heard a huge cluck / bang from underneath the car and it bogged and didn’t want to move. I then stepped on the gas because of the Car behind me getting to close and my traction control light started to flash and the car started to shake and feel very uncomfortable to drive . After that I realize only the two front wheels of the car were working and even at low cruising speeds the car feels very unsafe and shakes and hear noises I never heard before the part that is causing this is the transfer case and transmission thus there are many other people who have had this same issues ranging from 21 to 23 tlx type s with 15k miles to 100k miles

Transmission splines went out and transfer case has also failed which is only sending power to front wheels

On 07/01/2026, at approximately 8:00 AM, during steady acceleration, flashing of MIL with loss of power presented northbound after merging from 235 west bound to I-135 north bound near Park City, KS. Particularly dangerous resulting in near rear end collision. Upon taking nearest exit ramp, attached BlueDriver .OBD II reader, and fault code P0303 - Cylinder 3 Misfire and U0401-68 PGM-Fi/ECM/PCM system event code was logged, with multiple warning indicators that safety system, AWD, brake, and other systems were disabled. Note, vehicle has had TSB 20-053 update w/ flash of PGM-Fi which did not resolve the fault, fault associated with hot and humid climates or period of rain fall, apparent water vapor, condensate build up in intercooler. For Honda Accord and Acura RDX w/ 4 cylinder 2.0 TDGI engine TSB includes redesigned intercooler replacement, that is not available for TLX 21-25 which is currently out of production. This has occurred previously during humid and hot weather, but no inter...

2021 Acura TLX Type S SH-AWD. Total mechanical failure of PTU/transfer case spline interface at 29,800 miles within factory powertrain warranty. Vehicle operated silently in FWD-only with no warning lights, no fault codes, and no dashboard alerts — consistent with all complaints cited in NHTSA Defect Petition DP26001 (opened March 6, 2026, NHTSA #11712885). Failure confirmed by dealer via lift test: propeller shaft and rear wheels stationary while fronts spun. During actuator test, Check AWD System light illuminated for the first time — because the lift removed road-induced wheel rotation that had masked the failure from the ECU throughout normal driving. This is the only condition under which this failure mode is electronically detectable. Dealer replaced transmission (remanufactured ATR kit) and PTU under warranty. Repair took 38 days. CRITICAL-THIRD PTU REVISION: Replacement PTU installed was part #29000-5YK-070. Known revision history: -050 (original, confirmed failure part) → 06...