1990 Volkswagen Vanagon Complaints

CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING ANTI FREEZE WILL LEAK FROM THE ENGINE CAUSE AND DISTRACTION TO THE CONSUMER. DEALER NOTIFIED. TS

WHEN THE WEATHER TURNED COLD THE JUNCTION OF A SMALL, PLASTIC FUEL LINE WITH AN OVERLAPPING RUBBER FUEL LINE (HELD TOGETHER WITH A LARGE CRIMP CONNECTOR) STARTED TO LEAK DIRECTLY ON THE DISTRIBUTOR CAP. THE RUBBER IN THE FUEL LINE HAD DEGRADED AND CRACKED. THIS CRIMP CONNECTOR COULD NOT BE TIGHTENED OR EASILY REPLACED TO ELIMINATE THE LEAK. MANY EUROVAN OWNERS ON THE INTERNET HAVE REPORTED SIMILAR FUEL LEAKS. I COULDN'T AFFORD TO TAKE THE VEHICLE IN TO THE DEALER FOR REPAIR SO I REPLACED THE DEGRADED RUBBER HOSE MYSELF, USING RUBBER HOSE FROM AN AUTO PARTS STORE AND SCREW-TYPE STAINLESS STEEL HOSE CLAMPS. *AK

PLASTIC CROSSOVER HOSE ON TOP OF FUEL WAS CRACKED & LEAKED FLUID. THE FUEL TANK IS LOCATED IN FRONT OF ENGINE. WILL BE TAKING VEHICLE TO DEALER. *AK

MY 1990 VW VANAGON HAD NUMEROUS OCCASIONS OF INTERMITTENT POWER LOSSES FROM THE TIME OF PURCHASE IN 1990 UNTIL DECEMBER 1998 WHEN VW PART NUMBER 025906302A WAS INSTALLED. SEVERAL OF THESE POWER LOSSES RESULTED IN NEAR ACCIDENTS, ONCE WHEN PASSING A SLOW MOVING TRUCK ON A TWO LANE INTERSTATE WITH ANOTHER TRUCK RIGHT BEHIND ME, SUDDENLY THE ENGINE COMPLETELY STOPPED FOR SEVERAL SECONDS. ONLY THE ALERTNESS OF THE TRUCK DRIVER BEHIND ME IN SLOWING QUICKLY PREVENTED AN ACCIDENT. THE JACKSON WY DEALER COULD FIND NOTHING WRONG WITH THE VEHICLE. ON A RECENT TRIP TO WYOMING FROM CALIFORNIA THE INTERMITTENT POWER LOSSES REOCCURRED. AN INDEPENDENT (VW TRAINED) MECHANIC IN JACKSON INFORMED ME THAT A DESIGN DEFECT WHICH AFFECTED ALL VW VANAGONS FROM 1985 ON REQUIRED A NEW WIRING HARNESS TO THE ENGINE AIR CONTROL SYSTEM. THE VW DEALER IN IDAHO FALLS CONFIRMED THAT ALL SUCH WIRING HARNESSES SHOULD BE REPLACED, BUT STATED THAT I WOULD HAVE TO PAY FOR IT AS THERE WAS NO RECALL BY VW. THE PROBLEM IS EX...

IGNITION COIL AND WIRES, DISTRIBUTOR CAR AND ROTOR AND OXYGEN SENSOR FAILED.