-
Steering, suspension
03/12/2026
While driving at approximately 20mph, the front passenger-side steering knuckle suffered a catastrophic structural failure, snapping completely in two. This resulted in an immediate loss of steering and suspension control. Inspection of the fractured part by a mechanic revealed significant orange oxidation (rust) inside the metal cross-section of the break. This internal corrosion on a 2-year-old vehicle indicates a manufacturing defect (casting porosity or inclusion) that allowed the part to weaken and fail prematurely under normal road stress.
-
Fuel/propulsion System
01/20/2026
Check engine light came on after attempting a remote start and failed. Upon using an OBD-II code reader, it gave the code: P2421 - EVAP Vent Valve stuck open. This part is not covered under the 8/80k federal emissions warranty but is still an issue and is affecting emissions. There were no other alerts or warnings issued before attempting the remote start that caused the issue.
-
Unknown Or Other
12/19/2025
Vehicle was parked in my driveway. My wife and I were about 10 feet from it working on another vehicle when we heard a loud pop. We looked over at the vehicle and the sunroof has exploded. It was bubbled upward and completely shattered. I contacted my VW dealer and we slowly drove the car to the shop and left it. The dealer said it probably wasn't covered under dealer warranty because it was glass. It just shattered out of the blue, this should not be my fault or at my expense.
-
Power Train, electrical System, engine
08/15/2025
The contact owns a 2024 Volkswagen Jetta. The contact stated while driving approximately 35 MPH up an incline, the hill assist system engaged. The contact stated that while descending the incline, the hill assist was still engaged. The contact pulled over and turned off and restarted the vehicle to disengage the feature. There was no warning light illuminated. The contact stated that the failure was intermittent at first but had gradually become a recurring failure. The contact stated that the vehicle had additional failures with the transmission and the rear brakes due to the hill assist not disengaging as needed. The contact stated that the manual transmission was slipping out of gear and the rear brakes showed premature wear on the pads. The contact had taken the vehicle to several dealers. The contact stated that one dealer recommended that the transmission be replaced. The contact had taken the vehicle to another local dealer who was unable to duplicate the failure. The vehicle wa...
-
Electrical System
12/11/2025
The vehicle’s SOS/emergency call system has been inoperative since the vehicle was purchased. At delivery, the emergency call function did not work and displayed error messages. The vehicle was taken to an authorized Volkswagen dealer, and the OCU (online connectivity unit) module responsible for the SOS system was replaced under warranty on 3/17/2025 at approximately 6,294 miles. After the repair, the system functioned temporarily. In December 2025, the SOS system failed again and now displays an “Emergency Call Function Not Available / Please Service Vehicle” warning. The dealer has confirmed the same OCU module has failed again and must be replaced a second time. When the system is inoperative, the vehicle cannot automatically contact emergency services after a collision. This is a safety concern because the emergency call system is intended to function at all times in the event of a crash.
