-
Engine
08/25/2025
My 2023 vehicle has needed coolant topped off every 5-10K miles. This appears to be a very common occurrence for several owners however dealerships are just telling folks to top off as it's due to evaporation (it's a closed system and shouldn't evaporate). It is due to a faulty head gasket that VW even later redesigned. If you review reddit and numerous forums about the 1.5T produced before July 2023 it is a known issue that caused VW to redesign the headgasket. The powertrain warranty on new vehicle purchases is very short (50K miles) so they avoid replacing and tell folks to just "top off" until the warranty expires.
-
Electrical System
07/15/2025
The SOS Module has failed three times over 24 months of ownership. Each time, the dealer replaced the module and the faults comes back. This failure means I cannot contact VW for help in case of accident or breakdown. Part number: SWA-035-283-D
-
Engine
05/01/2025
While driving home from work (I travel with the railroad weekly) on Thursday, [XXX], I had my vehicle set on cruise control going west on [XXX] in TN. Out of nowhere, my engine overheated and I lost my coolant. Upon pulling over, I observed no trail of coolant and nothing leaking under my vehicle. I refilled the coolant and made it home. The next morning, my coolant tank was empty again. I took it to my local VW dealership and was informed that the head gasket needed to be replaced. Upon research, I found that on August 17th, 2023, VW put out a Technical Service Bulletin stating that the "Original engine production head gasket design can lead to coolant leaks." This Bulletin did list the engine for my vehicle purchased that year. I was told that "Our manager name is Tim. He informed me that TSB is sent out when they are seeing these issues occur. It is a tech tip to help the technician diagnosis the vehicle. Your vehicle is out of warranty therefore it wouldn't be cover." The engine...
-
Service Brakes
01/13/2025
The rear brake calipers are not fully opening, causing the pads to drag on the rotors. The dealership has replaced the pads per instructions from VW Engineering; however, per the dealership, they state that it's a software problem causing the calipers to drag against the rotors and VW hasn't issued any software updates to fix the known problem. They did "extend" the brake warranty for consumables to 2 years/24000 miles at no cost the customer however, the software problem has not been fixed and VW is ignoring the problem. The front breaks are also gripping and causing a varnish build up and there is no fix for that problem, either. I have a 2023 VW Jetta SE with only 14,362miles and I've had to have the breaks serviced 3 times due to the breaking problem.
-
Service Brakes
04/09/2025
Rear brakes worn prematurely with only 16k miles on a brand new purchased 2023 VW Jetta. Dealer said, VW will not replace until the brakes at 2mm and the warranty will expire next month and I will end up paying for it out of my pocket.
