-
Structure
10/13/2023
The contact owns a 2004 Toyota Tundra. The contact stated that while the vehicle was in for the State Inspection, he was informed that the sub frame underneath the front driver's side door was severely corroded. The vehicle was taken to an independent mechanic, and it was determined that the sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 171,000.
-
Suspension
09/06/2011
The contact owns a 2004 Toyota Tundra. The contact stated while driving 25 MPH, the front driver's side lower ball joint detached, causing the driver's side wheel to separate from the vehicle, and the vehicle lowered to the ground. The vehicle was towed to the residence, where it was diagnosed by an independent mechanic. The mechanic determined that the front driver's side lower ball joint needed to be replaced. The mechanic replaced the front driver's side and passenger's side lower ball joints. The contact stated that the vehicle was previously repaired by an unknown dealer for the same failure. The contact stated that the front driver's side and passenger's side ball joints failed several times while driving and were replaced; however, the failure persisted. Additionally, the contact stated while driving approximately 60-65 MPH, the driver's side ball joint failed, which damaged the running board, the brakes, the driver's side door, the tie rod, the coil springs, the lower control a...
-
Suspension
08/10/2023
Severe rust to the frame of my 2004 Toyota Tundra SR5 double cab. There are holes through the frame. Took it for an oil change and the mechanic told me to be careful. Crawled under the truck and couldn't believe how bad it was.
-
Unknown Or Other
08/10/2023
I have a 2004 Toyota Tundra SR5 that was part of the frame rust replacement campaign. It was brought into Bob Rohrman Toyota in Lafayette, IN and determined that it did not meet the criterion for replacement. I now have a sway bar bracket that rusted off of the frame. No mechanics or body shops will touch it and I was told there is nothing to even weld a new bracket to and the engine mounts are just a matter of time before rotting away. The truck only has 118k miles and zero body rust. I have lost value in this vehicle because I cannot sell it and the dealership and Toyota both refuse to remedy the situation.
-
Suspension, structure
07/10/2023
Informed by Al Serra at 4200 Bay Rd in Saginaw, MI 48603 that there are holes present in the frame that pose a dire safety concern. This is a known issue with this model year, but Toyota says the recall is no longer valid.
