-
Structure
02/01/2026
Hinges on the trunk wore out abnormally fast causing the struts to fail and trunk to misalign causing further lift gate damage. Caused a roughly one inch gap in the trunk there light was visible and wind can be felt through. If not addressed the hinge will rip off and the trunk will go with it.
-
Engine
05/09/2026
Coolant bypass valve leak. An known issue however dealership will not pay for repairs due to vehicle having 106000 mile. 6000 over what the bulletin 24TE04 states it will cover.
-
Electrical System, engine
04/20/2026
Toyota made a defective coolant valve in their 2019-2021 cars that leaked spontaneously in these vehicles. Over 950,000 cars have been affected to date, including my 2020 Rav4. They are aware of the issue and made a customer support program for this issue which led to engines overheating/electrical code problems, which can cause a severe safety issue if left unrepaired. The program however has a limitation until November 2025 or 100,000 miles whichever comes first. When I was alerted of this, I brought my car to the dealer for service, but they wouldn't replace the part because it wasn't leaking too much at the time to need repair. However, just 4 months after the primary coverage expired, my engine code went off and when I brought my car, the coolant valve turned out to be defective and leaked into the electrical wire harness which then also had to be replaced in addition to the coolant valve. The repair cost was $1200 and both were required to keep the car driving safely and reliably...
-
Engine And Engine Cooling
05/07/2026
The contact owns a 2020 Toyota RAV4. The contact stated that while the vehicle was parked, coolant was observed leaking from the engine compartment with no warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed that the engine casing had failed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but denied the engine replacement request because the vehicle had previously been serviced by an independent mechanic for engine maintenance. The contact stated that the failure was related to NHTSA Campaign Number: 20V064000 (Engine and Engine Cooling). The approximate failure mileage was 34,678.
-
Structure
09/27/2025
I am having a failure of my liftgate. My liftgate hinges are cracked and pulling away. The welds are cracked and weak. The liftgate does not close properly. I fear my liftgate will fall off and this could cause safety concerns for other vehicles behind me as well as potential harm to passengers in the back seat. I have a call into the dealer where my 2020 RAV4 Adventure was purchased but have not heard back from them yet.
