2019 Toyota RAV4 Complaints

Display of RAV4 Hybrid is malfunctioning as it randomly turns on and off at frequent intervals, the screen turns on an off in a similar manner, the display controls are not operative even if displayed. This occurred right after the Dealer (355 Toyota of Rockville, [XXX] ) conducted a recall procedure on a wire harness. Immediately after these repairs, it was noticed that the display started to malfunction. It has never malfunctioned before. I went back to the Dealership and the manager said that the display problem was unrelated to the recall maintenance. So I am reporting it here. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving down a county road at approx 40mph, the glass of the sunroof of my 2019 RAV4 suddenly cracked, with shards falling down into the vehicle. There was no apparent cause or impact. After moving to a safe location to further inspect, I noticed the following details; - the rectangular glass of the sunroof is cracked through at multiple points along the edges of the pane, and a "web" pattern of partially shattered glass extends across the whole pane. - there is no pattern that I would associate with an impact spot and no evidence of impact from any falling object. At the time, I was driving under open skies in a rural area, not under any trees, overpasses, etc. - the glass appears to be buckled outwards, as though internal cabin pressure was a factor - the car had been parked outside my office all day, the day was overcast with a high in the 80s. There was no rain/hail/etc. Overall, the lack of apparent impact and outward-buckling pattern raise concern for a material or man...

While driving the 2019 Toyota RAV4, I found that the steering wheel was getting hard to turn and the car kept making grinding sound when turning. Due to I was short on time, I asked an old mechanic friend to check the RAV4 out before my road trip. He was unable to get the vehicle back; therefore, I used my other vehicle. While I was out of town the Mechanic contacted me, and ask if the car had been in water and I replied no. He suggested that I might want to see if there’s a recall. I googled recall for RAV4 vehicles and found that a recall had been issued for certain groups of power, steering boxes. This may allow water to enter the box that could corrode and cause loss of power steering that could cause an accidents. I’ve reached out to several Toyota representatives with this issue, but have been unsuccessful and getting them to see that this car may have been overlooked.

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at an undisclosed speed, an orange steering symbol appeared on the instrument panel accompanied by the message: "Power Steering Malfunction, Steering Power Low, Visit Your Dealer." An initial inspection by an independent mechanic indicated that the electrical power steering and the rack and pinion assembly needed to be replaced. Subsequently, the vehicle was taken to a dealer, where diagnostic testing confirmed a defective power steering system. Following a software update performed by the dealer, the warning symbol transitioned to red, accompanied by an audible alarm and a significant increase in the physical force required to steer the vehicle. Restarting the vehicle temporarily reverted the warning light to orange and restored steering functionality. Upon investigation, the contact discovered NHTSA Campaign Number: 20V373000 (Steering); however, the VIN was not included in the recall. The manufacturer was not...

Rav4 2019 - We lost engine power while driving on the highway at 75 mph. We were in the #2 lane and were fortunate to be able to coast to the side of the road. Quite scary as there were semi trucks behind us.We had been driving for approximately 3.5 hours on the highway at 70-75 MPH. The outside temperature registering on our vehicle began at 110 and continued to increase on up to 118 degrees at the time of the incident. When we lost engine power, the following errors began flashing on the dashboard: PKSB Malfunction, Pre Collision System Malfunction, Secondary Collision Brake System Malfunction. We cleaned the sensors, turned the car off for 5 minutes and then turned it back on. Same warnings appeared. Got towed to the Toyota dealership. Next day all malfunction warnings gone. Car was behaving normally. Toyota service team was unable to reproduce the problem. They inspected the electrical, battery, sensors, etc. but could not find anything. Ultimately the service lead state...