2017 Toyota Prius C Complaints

The contact owns a 2017 Toyota Prius. The contact stated while driving 10 MPH and pulling out of a parking lot, the vehicle lost motive power and made abnormal sounds. Several unknown warning lights were illuminated. The vehicle failed to restart, and was towed to the dealer, where it was diagnosed that the head gasket was blown, causing damage to the engine. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, where the same assessment was made. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because the vehicle was out of warranty. The failure mileage was approximately 80,000.

While filling my Prius with gas, as soon as I started pumping, it spewed gas all over my arms and shirt, as the gas would not go down the pipe into the gas tank. My mechanic explained that gasline exhaust valve was stuck causing the gas to spirt back out the intake opening. This part had to be replaced. Firestone replaced it for a total of $337.08, however, the dealer would have charged more. It was not covered as a defect issue. The experienced mechanic said that he had seen this problem on several Toyotas. This is hazardous and Toyota should repair those that exhibit this problem; also they should change their design so that the exhaust valve does not fail causing gasoline to spill on the person pumping gas and all down the side of the car onto the cement pavement.

The rear quarter panel is peeling off

When filling gas, a near-empty Prius overflowed almost immediately, splashing fuel over the car, the ground, tires, and my feet! Gas is flammable and not good to get on one's skin. Firestone experienced/certified repairman said that he's repaired many Toyotas with the same problem. No advanced warning was presented. Last time I filled it before this incident it worked fine. Technician said that the air-exhaust that permits air to escape while gas is being delivered to the tank had failed to work properly, causing the fuel to spew back up the gas line and on to the car/ground. He had to order a part from Toyota and replace it. This cost me $337 for part and labor. I believe this is a malfunction that Toyota should cover. This part should not fail as it could start a fire and contaminate the car, ground and put petroleum on people.

For the past year or so we have had issues with the vehicle not starting properly. If we leave the radio, wipers, heater, or air conditioner in the ON position when we shut the car off, or a window down a little on a hot day, a sensor triggers a Low Battery error code. We have had the battery checked and it is NOT low. When this happens to start the car we need to get a jumpstart from someone. This limits where we feel safe driving to as in a remote place where not many other people and cars are it would be more difficult to find someone to give us a jumpstart. On occasion, we have had to call a towing service to come to help us, which requires sometimes a long wait. The car starts right up once the connection to the other vehicle's battery is made. We should not need a checklist to make sure everything is turned off before we leave the car to avoid this non-starting issue.