2003 Subaru Baja Complaints

My cars abs light came on and the speedometer, rpm gauge, and electrical system started failing while driving. I immediately pulled over. The car caught fire around the alternator. The fire was minor, as I found the damage after towing the car home. If it had been worse, I could’ve been injured and burned. When I went to fix the car, we found that the wires were taped together with electrical tape and the other end had a form of glue on it. After we bought the car, the dealership kept calling checking on the vehicle, making me believe it was a known issue by them. This issue will cost me to fix the wiring, but I am unsure how much yet.

Vehicle purchased in NC in April, 2025. Registered the vehicle in VA (where I live) a week later once I received the NC title. On [XXX], I took the vehicle to get it inspected. It failed the Virginia State Safety Inspection for the suspension - rust on the rear subframe near right rear wheel well. I found the following information online with regards to this issue: These recalls were issued for the 2003-2006 Subaru Baja , specifically those in the "salt-belt" states for "poor paint quality on the subframe components which led to rusting and potential for subframe failure." The recall numbers that I was able to locate online are O3V-153 and WWM-96. I have already reached out to the Customer Advocacy Department of Subaru of America and they are unable to help me because this particular VIN was not tied to this recall. I am unable to get this vehicle inspected because it does not pass due to this issue. This was a KNOWN issue for this year make and model vehicle in the states in...

At the beginning of April, I purchased a 2003 Subaru Baja from Roseville Auto Center for $10,500 and was reassured by the salesman that it passed a safety inspection and that there were no leaks in the head gasket. I did my own inspection under the hood and underneath the vehicle. I found there to be undercoat sealant which made sense as the vehicle was from Pennsylvania. I asked about the rust condition of the car to which I was once again reassured that it was okay. I took the car home and the following week I took it to my mechanic to see where I should start on modifications and upgrades. However, upon doing a multipoint inspection with the car on a lift he discovered that the undercoat sealant had been sprayed over duct tape to conceal rust holes in the running boards. Further, the undercoat had been sprayed after the frame had gotten significantly damaged by rust, not as a preventative measure as it’s intended to be used. The frame has severe rust damage as does the steering, sus...

The contact owns a 2003 Subaru Baja. The contact stated that upon inspection the vehicle, the contact discovered severe corrosion to the rear subframe. The contact called the manufacturer and was referred to a specialist. The contact was yet to receive a call back from the specialist. The dealer was notified of the failure and the contact was informed that other model vehicles had experienced a similar failure. Upon investigation, the contact discovered that there was no recall for the subframe corrosion. The vehicle was not repaired. The failure mileage was approximately 180,000.

Subaru water pump pulley center hole was improperly machined