2022 Subaru Ascent Complaints

The front exhaust pipe on my 2022 Subaru Ascent cracked at approximately 77,800 miles. The component is available for inspection. Prior to diagnosis, I noticed a rattle/fluttering noise coming from the undercarriage during acceleration. The problem was confirmed by an authorized Subaru dealership. Subaru has issued TSB 09-106-23 acknowledging this is a known design defect affecting 2019-2023 Ascents, and has redesigned the part to correct the issue. Despite being within the 8 year/80,000 mile federal emissions warranty period, the dealership denied warranty coverage, claiming coverage only applies in California and Maryland. This is incorrect - the federal emissions warranty applies nationwide. The dealership quoted over $1,000 out of pocket for a known manufacturing defect on a 4 year old vehicle. The cracked exhaust pipe poses a safety risk as exhaust fumes can enter the vehicle cabin. I am requesting NHTSA to investigate whether Subaru is improperly denying federal emissions warrant...

The contact owns a 2022 Subaru Ascent. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. The vehicle experienced a loss of power steering assist, the speedometer was inoperable, and the transmission failed to shift into gear. The vehicle was taken to an independent mechanic, who inspected the brakes and reset the check engine warning light, but the failure persisted. The vehicle was then taken to the dealer, who determined that the rear radar sensor module beneath the rear bumper had corrosion from car wash or road salt. The dealer replaced the rear radar sensor module and sealed it with silicone. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 60,000.

Exhaust "Nut" mysteriously went missing, causing noises, and Subaru technician stated to replace exhaust if issues persist. Vehicle was under warranty, only been serviced by certified Subaru technicians, and multi-point inspections were allegedly performed during every service, however, the exhaust "nut" were somehow still went missing.

The front driver seat cushion/seat cover is deteriorating and ripping at the front portion of the seat. While driving, I can feel road vibration and impacts through the driver seat much more than normal, and the seat no longer feels properly cushioned or supported. I am concerned this affects the driver seating position, comfort, and ability to maintain proper control, and it creates a distraction while driving. The failed component is the front driver seat cushion/seat cover and it is available for inspection upon request. I have seen Subaru Service Bulletin 12-273-19 for earlier Ascent model years describing redesigned front seat cushion trim covers due to early wrinkling/durability concerns, and my vehicle appears to have a similar front seat cushion/cover failure. The problem has not yet been confirmed by a dealer or independent service center. The vehicle/component has not yet been inspected by the manufacturer, police, insurance, or others. There were no warning lamps or messages...

The contact owns a 2022 Subaru Ascent. The contact stated that while operating the vehicle, there was a whining sound coming from the transmission, and the vehicle failed to properly accelerate. The vehicle was slowly driven to the local mechanic, who diagnosed the vehicle and determined that the transmission had failed and needed to be replaced. The transmission was replaced, and the vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 115,000. The VIN was not available.