2018 Mini Countryman Complaints

The contact owns a 2018 Mini Cooper Countryman. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The contact stated that the steering wheel was excessively difficult to turn. There was no warning light illuminated. The vehicle was driven to the shoulder of the roadway. The vehicle was taken to the dealer where it was diagnosed with ECM failure. The contact was informed that the ECM needed to be replaced. The vehicle was repaired. In addition, the contact was advised that the failure was a known failure with the vehicle while using the Click and Drive device. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was 19,000.

While driving, the steering wheel gets stuck and very hard to maneuver. I have seen a recall for this car but when i entered by VIN, it was not included on the recall. The problem had happened several times. There was a time when everything was working fine, turned off the engine to put gas and when i turned it on to drive, i had a hard time steering. I had to park for a long time (since i was at Costco decided to come inside the store), when i turned on engine, it was gone and working properly like the problem did not happened at all. There were still times that when i turned it off for a little bit to pick up something from a restaurant, when i come back, the steering wheel looks like it was stuck and unable to make left or right turns. It does not happen only when car is turned on and off, it also happens while driving. When i was in a roundabout, steering wheel also has locked/got stuck. I have had our mechanic check this issues twice but he could not find any problem.

My engine malfunctioned after the module under the back seat was wet from an unknown water leak in the vehicle. My vehicle lost power without warning until I came to a complete stop on the side of a very busy highway. I'm not sure if the repair center kept the faulty module or not I would have to check. I know leaks have been a problem with my model in previous years but when I checked my VIN there were no recalls. This is a very dangerous defect and should be fixed.

Fuel sensor failed and due to tank pressure that would not release properly, according to repair shop. Among other safety issues, this caused me to not be able to open the gas tank to refill the gas tank. This has been ongoing. At first the gas flap was repaired (2x) and ultimately the fuel sensor was entirely replaced at my cost. All repairs were done at New Country Mini in Hartford, CT. The repair shop should provide history of repairs over the several years as Mini is denying the seriousness of the defect. I’ve notified mini.

•What component or system failed or malfunctioned, and is it available for inspection upon request? I had brake caliper repaired on front right wheel, on 5/5/20. Had to have service on same brake caliper on 10/5/21 - revealed caliper froze causing excessive bakes wear. •How was your safety or the safety of others put at risk? Potential of brake failure. •Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Dealer repaired work- Passport Mini of Montgomery County, 820 Russell Ave, Gaithersburg, MD, 20879 •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Unknown •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No