2014 Mini Cooper Coupe Complaints

The contact owns a 2014 Mini Cooper. The contact stated that the front driver's side and passenger’s side doors and windows failed to properly close. The vehicle was taken to the local mechanic who diagnosed the vehicle and determined that the failure was caused by a faulty foot well module which caused the electrical power windows to malfunction and the doors to not properly close. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 23V337000 (ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 80,000.

Engine motor mount sheared, allowing motor to interact with and bounce directly on the frame, and stressing the other connections and components. Dealer indicated this is a very common problem for this car model and is likely a design issue, and even had another example of a sheared mount on display in order to show others with the same issue.

The fuse box JBE module has a Quality Assurance problem with a solder connection to the NEC low pressure fuel relay. This is a known issue with BMW/Mini. The car suddenly stalls without warning. If the driver is not keen or if traffic patterns do not allow, the car can be left in very dangerous situations on the highway or in the middle of intersection. The repair for this problem is widely distributed online via blogs and YouTube, but replacement modules are $1500 (part only) and these modules are not available until at least October 2023. There are no warning lights or other warnings prior to the incident. While I am not aware of any serious injuries, it is only a matter of time before someone is t-boned at an intersections. This part MUST be immediately recalled due to the safety risk. The images below show the JBE fuse box housing as well as the PCB where the cold solder joint can be seen. I have circled the cold solder joint in the close up picture.

The contact owns a 2014 Mini Cooper. The contact stated that while driving approximately 25 mph, there was smoke detected from the vehicle. The vehicle caught fire without warning. There were no reported injuries, air bag deployment, or crash. The fire department distinguished the fire. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was towed to a lot. The manufacturer was not notified of the failure. The failure mileage was approximately 84,700.

TURBO CHARGER HAS SYSTEMATICALLY FAILED OVER THE LAST YEAR, WITH WORSENING EFFECTS. THIS CAUSES THE CAR TO AUTOMATICALLY GO INTO "LIMP MODE" AND CUTS POWER. THIS IS DANGEROUS FOR DRIVING ON THE HIGHWAY. THIS IS A COMMON COMPLAINT WITH MINI COOPERS WITH MANY, BUT NOT ALL YEARS RECALLED.