2013 Mercedes-benz ML-Class Complaints

NHTSA VEHICLE SAFETY COMPLAINT SUPPORTING STATEMENT Vehicle: 2013 Mercedes-Benz ML350 I am submitting this complaint regarding a continuing safety concern involving water intrusion and electronic system damage in my 2013 Mercedes-Benz ML350. My vehicle was subject to a Mercedes-Benz recall involving water intrusion and related components. Despite recall-related repairs being performed, moisture and water intrusion concerns remain unresolved. During the diagnostic process, Mercedes-Benz personnel identified evidence of water and humidity in areas associated with vehicle electronics and control modules. The vehicle has experienced repeated mechanical and electronic issues following discovery of the water intrusion condition. Multiple repair facilities have been involved, and I have incurred significant diagnostic and repair expenses while attempting to determine the full extent of the damage. The primary concern is not ordinary wear and tear. The concern is that water intrusion has...

Re: My 2013 ML350- Intermittent Start/ Vehicle cutting off while in heavy traffic. Fuel Pump and Fuel modulator failed due to water collecting in the spare tire wheel-weld causing water intrusion into the fuel system. I paid out of pocket for this service twice, AND then found out from MB Tacoma there was a RECALL with the exact same issue. I took the vehicle in to the closest dealer- Seattle Mercedes to handle the outstanding recall issues. I was advised to contact MERCEDES BENZ USA GOODWILL DEPARTMENT. My initial claim was approved, as I submitted ALL DOCUMENTATION of the repairs related to this issue. NOW, after 5 months of my RECALL REIMBURSEMENT CLAIM BEING BOUNCED AROUND by customer service agents that were not trained to handle recall issues- my dealership needed approval to process it. I even provided MB-USA w/a Bulletin # (FROM MB-USA) that clearly states to claim reimbursement IF THESE PARTS FAILED AND THE CUSTOMER PAID OUT OF POCKET.

On December 6, 2025 I purchased a used 2013 Mercedes-Benz ML63 AMG from Jaguar Land Rover Willow Grove (Piazza Auto Group) in Pennsylvania. The delivery documentation for the vehicle included a written service commitment stating: “Replace air compressor for suspension system.” On January 23, 2026 at approximately 6:30 PM, while operating the vehicle at highway speed on the [XXX] in [XXX] , the vehicle experienced a sudden cooling system malfunction. An “Engine Overheat – Shut Off Engine” warning appeared on the instrument cluster and steam began emitting from the engine compartment. Because the failure occurred while traveling at highway speed, the driver was forced to execute an emergency maneuver across traffic lanes in order to reach the shoulder safely. The vehicle became disabled and required towing. The vehicle was transported to a Mercedes-Benz dealership for inspection. Initial repairs involved replacement of the coolant reservoir and hose assembly. Within several days the...

The contact owns a 2013 Mercedes-Benz ML350. The contact stated that while driving approximately 40 - 45 MPH, the vehicle stalled in the middle lane. The driver was able to push the vehicle safely to the roadside. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed, and determined that the fuel pump needed to be replaced. The vehicle was repaired. The following day, it took two minutes to start the vehicle. The vehicle was drivable, but the vehicle eventually stalled while driving. The vehicle was towed to another local dealer, Mercedes-Benz of South Orlando (4301 Millenia Blvd, Orlando, FL 32839), where it was diagnosed with a faulty fuel sensor and control valve. The parts were replaced. The contact stated that the fuel pump was replaced four times, but the failure persisted. The manufacturer was contacted and escalated the failure was escalated to an engineer for assistance. The failure mileage was approximately 96,000.

Good morning ! I am an owner of a 2013 ML 350 . I live in San Diego ,CA ,92103 . I was driving my car on [XXX] and it was raining a lot . After around 30 miles I got to my destination parking area and my car died 20 feet away from the parking zone .I tried to reignite it but it wouldn’t start . I checked it with a OBD2 scanner and it was indicating a code U0109 - Lost communication with fuel pump control module . After looking into solutions and reasons for the issue online I came across a post regarding an existing recall with NHTSA with ID 22v955 regarding water intrusion in the spare wheel well portion of the trunk( The Wheel well is not water proofed and doesn’t have a drain port for water to escape ) . I proceeded with inspecting the area and of course it was full of water . The fuel pump control module is located in that area and it was damaged which shorted it and cause the malfunction of the vechile and the error code U0109 stated above . Tried calling Mercedes Benz bu...