2021 Mercedes-benz GLS-Class Complaints

The vehicle suffered a sudden, catastrophic 48V mild-hybrid electrical power supply breakdown and complete system failure while traveling at highway speeds during a cross-country move. The sudden failure forced an emergency lane change into an isolation zone just off the highway. The sudden failure left the cabin completely powerless with no operational safety systems, hazard lights, or air conditioning in extreme 100+ degree heat. This roadside isolation created an immediate physical hazard and directly inflicted acute heat exhaustion and severe dehydration, requiring a subsequent emergency clinical medical evaluation on July 5 for lingering environmental exposure symptoms. Subsequent forensic diagnostics performed at an authorized secondary dealership (Mercedes-Benz of North Scottsdale) captured digital video evidence of active, high-voltage 48V electrical arcing across a completely loose, un-torqued main grounding network connection left by a prior repair facility (Mercedes-Benz of...

48V battery has repeated failures where I'm driving. safety concern, When it fail, it will pop up warning1) only drive below 50 miles/hour; then it becomes2) stop vehicle immediately; then ) multi-media system suddenly shut off while I'm driving. I tested by 48V battery which only has below 60% health. with 4 error code all related to V48 battery and management system: B183214; B183216; B183217; B183371; 48V battery is under Emission control component warranty which has 5 years/50000miles in Federal for MediumDutyVehicle and 7 years/80000 in WA state. My car is listed as MediumDutyVehicle in Mercedes service book. Mercedes refused to replace my unhealthy battery. Mercedes Charging me diagnosis fees for failure of V48 Battery. this should be waived since the part is under warranty Mercedes refused to provide battery health report to me even I explicitly asked from them, they just cleared the code and told me my battery is fine

Both rear wheels on this vehicle have developed cracks which leads to tire pressure loss. Apparently, this is a common issue with Mercedes' heavier vehicles like the GLS and S series sedans. To be clear, I did not hit anything. I did not do any unusual driving. Both rear tires are fine. While you expect that certain components on a vehicle will have problems, it is also reasonable to expect that wheels will not crack prematuraly. Mercedes is aware of the problems. They were named in a class action lawsuit that was dismissed because cars were out of warranty. Warranty or no warranty, this is a major safety issue as a loss in tire pressure can be catastrophic.

The contact owns a 2021 Mercedes-Benz GLS580. The contact stated that after entering the vehicle, the contact became aware of an abnormally strong fuel odor inside the vehicle. There was no warning light illuminated. The vehicle was taken to two independent mechanics who referred the contact to the local dealer for assistance. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 83,000.

On [XXX], I was heading home from work traveling [XXX] on [XXX] through Atlanta's usual heavy traffic. I smelled smoke inside my car and saw fire flames coming from under my passenger seat. My initial reaction was to try to put the fire out with my hat without burning myself. Also, I had to try to navigate across multiple lanes of traffic without hitting anyone and avoiding anyone hitting me. Safely, i reached the side of the interstate and exited the vehicle. As I stood from afar watching my vehicle burn; the reality sat it that a few minutes earlier that could have been me trapped burning inside, injured or even death because something had failed in my vehicle. Later, when I finally arrived home, I started researching on the internet to see if anyone else had experienced problems with their MB 450 GLS catching fire. Surprisingly, I found that recalls had been issued in April 2022 and March 2024 for a possible fire risk from a 48volt loose ground wire issue under the passenger...