2004 Mazda RX-8 Complaints

No worries — here it is trimmed to under 2,000 characters: I am reporting a recurring safety defect on my 2004 Mazda RX-8 (VIN: [XXX] a repair under NHTSA Recall 1017E (Fuel Pump Ring / Discharge Pipe). Recall 1017E was completed on my vehicle on September 19, 2017. The same fuel leak has since recurred, with fuel vapor now entering the passenger cabin. Only a few thousand miles have been driven since the recall repair. The vehicle is currently at Della Mazda, Queensbury, NY at approximately 72,000 miles. On May 8, 2026, I contacted Mazda Customer Experience Center. Mazda confirmed the dealer submitted a pre-authorization request for recall coverage, which Mazda corporate denied, stating the recall was previously completed and further repairs are my responsibility. I have a chat transcript documenting this. A recall remedy that fails to correct the covered defect should not be considered complete. I am requesting NHTSA review whether Recall 1017E has produced recurring failures, dire...

For a year I have responded to every notice for a recall repair (7 total) Mazda has not repaired my vehicle or scheduled its repair. My recall ID is 016742248 and my Campaign Number is 100409. My car has a DO NOT DRIVE status and Mazda tells me I MUST drive the car 2 hours to get it repaired each way. And they refuse to transport y vehicle even thought I have told them in phone conversations about my cars do not drive status. The latest attempt for filing for a repay was 7-21-25 at 9:40am central time.

The contact owns a 2004 Mazda RX-8. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the engine. The dealer determined that the engine had no compression. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 60,000.

The electric power steering randomly pulls hard to one side while driving. There are brief spasms of forceful jerks each jerk is 1-2 seconds the series of jerks lasts 10-20 seconds and usually stops with power steering failure all while driving.

Engine naturally wears out especially after 200k miles due to friction in the natural design of the Rotary engine, resulting in losing its overall function such as turning off in the middle of a drive due to loss of compression from worn Apex Seals of the Rotary. The rotary engine requires a replacement of the Apex Seals to continue functioning normally to avoid any unpredictable accidents due to engine failure. An event occurred where my RX-8 went into limp mode in the middle of the freeway as i was commuting due a misfire from poor compression, this is more then likely a common event nowadays for RX-8 owners starting at the S1 2004 models with newer models soon to follow the same incident as me. This is completely unsafe especially traveling at 65 MPH