2016 Mazda CX-9 Complaints

2016 Mazda CX-9 2.5L Turbo Touring with 93,197 miles. In September of 2022, I noticed a sweet smell coming from the engine bay after coming home from work. I took my car to my mechanic on 9/30/2022 for an oil change and asked if they could figure out the "sweet smell" coming from the engine bay. When they were doing the oil change, they checked for leaks and noticed that coolant was leaking from cylinder head. Since it was out of warranty, I had my mechanic repair the issue. Which resulted in a complete cylinder head replacement. This is a know issue by Mazda and there is lots of documentation online for this as well. There has since been updated parts to repair this issue, but this should be a recall covered by Mazda. Cause this repair cost me $5,700 out of pocket.

My seat warmer caught fire and burnt a hole through the seat.

We noticed anti-freeze leaking from our car a couple of days ago and immediately brought the car to our local mechanic. The mechanic determined that one of the cylinder heads in the engine was cracked and was leaking anti-freeze. He said the car was unsafe to drive. He also told us that a TSB had been issued by Mazda for this problem ( Bulletin No 01-002/23, issued 02/10/23). This bulletin states "Residual stress generated during production in the cylinder head material may be greater than expected. The external force from the exhaust system when driving over bumps may cause unexpected force to certain areas of the cylinder head". Had we not noticed the leak, the engine could have overheated, causing the engine to seize at any time, any place. which could have led to a dangerous accident. An accident that could have occurred on a major highway and could have involved other vehicles as well. Our car has just under 80,000 miles, has been well maintained and garage kept. I do not understa...

I started smelling coolant after exiting the vehicle from a drive. Coolant level was very low. Adding coolant did not last long. I could not see where the leak was. The dealership evaluated and determined I had a cracked cylinder head and the car is leaking coolant near the rear of the engine. This could cause the engine to seize should coolant get into the engine. The dealer (New Rochelle Mazda) explains the cylinder head needs replacing. The dealer also observed bad rear sway bar links. One was detached. The car is serviced at the same dealership every 5k miles. The car has approximately 85k miles. The cylinder head has been repaired by the dealer under the extended warranty. Safety risk was moderate as the car could have stalled on the highway. The component was inspected by the warranty company and dealer only. The only warning lamps that showed up once were both brake indicator lights came on and the climate control would not warm the car.

Vehicle “surges” at idle. 300-500 RPMS at a time. Sometimes the brakes hold and sometimes not. Have nearly been in 3 collisions the last 2 days because of this issue. The ECM codes indicate throttle body or TPS issue, both of which have been unfounded. Vehicle has 63,000 miles. Researching this topic online found that many others have had this issue with no associated safety recalls noted. I am hoping to bring light to this so someone doesn’t have to be injured or killed to have this rectified.